Honeywell HON P095NG Series - 10.4 Lubricants and Threadlockers

Appendix
UsermanualforHONR100gaspressureregulatorwithHONP095NGpilot  89
10.4 Lubricantsandthreadlockers
Important!Allpartsmustbeslightlygreased.
Usethefollowinglubricants:
Application Remark Lubricant Partno.
O‐rings
Stationaryandmoving

Standardmodel:
Flatgaskets

Siliconegrease(jar) 27079
Diaphragms
Greasethedia‐
phragmgripbodyon
allsides
Siliconegrease(tube)
27081
DoNOTgreasethe
flatgrip

Valveshankslidingsurfaces
Greasefilmonly
Low‐temperaturemodel:
Slidingguides Siliconegrease(jar) 27993
Guidebushings 
MovingpartsinSAVcontrolgear
andswitchgear
High‐temperaturemodel:
Switchjacksandlockingsleeves PFPEgrease 102389
Controlballsandcontrolrollers 
Ballbearing 
Valvesleevesandvalvesleeve
gasketsingaspressureregulators

Siliconegrease 27052
Setpointsetscrews
Powerscrews

Assemblypaste 27091
Threadmaterialcombination:
Al/Al

Screw‐infittingsandfastening
screws

Springplatedepressions(pilot)

Devicesforoxygen
Important!Oil‐freeand
grease‐freeinstallation;only
antiseizeagentsarepermissible
Upperoxygen
pressurelimit:
260 barat60°C
Antiseizeagent 28211
Devicesforammonia

Antiseizeagent 28211

Application Remark Threadlocker Partno.
Maintenance(seepage44)
section
Diaphragmunits
LOCTITE
26688

Lubricants
Threadlocker