Howe 2000-RLE - Sanitizing Procedure

Maintenance


33


7. PourcleaningsolutionintoWaterSump
toaleveljustbelowthesideopening.

8. TurnPowerSwitch“On”for2‐3seconds
andthen“Off”againatIceFlaker
ControlPanel.Thiswillallowcleaning
solutiontocirculatefor30minutes. It
mayrequireseveral
30minutecyclesto
fullycleantheIceFlaker.

9. Aftercleaning,drainsolutionasshown
inStep5exceptkeepStopValveopen.

10. FillWaterSumpwithfreshwater.Turn
PowerSwitch“on”for2‐3secondsand
then“Off”againatIceFlakerControl
Panel.Thiswill
flushcleaningsolution
fromIceFlakerwhileitisbeingdrained.

11. Continue fillingWaterSumpwithfresh
wateruntilallcleaningsolutionis
flushedout.

SanitizingProcedure
1. Mix16oz.ofhouseholdbleachwith2
gallonsofwarmwater(90°F–115°F).

2. PoursolutionintotheWaterSumpto
thenormaloperatinglevel,thenre‐
circulatedthesanitizing solutionfor
approximately20minutesbyturningon
DriveMotorandWaterPump.

3. Drainsolutionand
rinsethoroughly
withfreshwateratleasttwice,
followingthetechniquedescribedin
CleaningProcedure#10.

4. AftertheIceFlakeristhoroughlyrinsed,
returntonormaloperationbyopening
watersupplyvalve,re‐adjustingOff‐
DelaySetting,andrestoring
refrigerationbyturningthePower
Switchbackto“On”.

AlternateMethod:Substituteanapproved
sanitizerdesignedforgeneraluseinfood
dispensingequipmentinstep#1.Mixsanitizing
solutionaccordingtoinstructionsonthebottle.








