Home
HySecurity
Gate Opener
SlideDriver 50VF2/3
HySecurity SlideDriver 50VF2/3 User Manual
4
of 1
of 1 rating
156 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
1
3
Table of Contents
Default Chapter
4
Slidedriver 15, 30F
4
Slidedriver 50VF Site Installation Overview
4
Slidedriver (All Models) 50VF Components
5
Table of Contents
7
Welcome to Hysecurity
12
Contact Information
13
Notices and Bulletins
13
Supplemental Documents
13
Important Safety Information
14
Important Safety Information
27
Emergency Stop Button
28
Emergency Release
28
Power
29
Installing the Earth Ground
29
Site Considerations
30
Wiring AC Power
30
Turning the Power Switch on
31
Wire Sizing and Runs
32
Low Voltage Control Wiring
32
Slidedriver Wiring Charts (Incoming Power)
33
Slidedriver 50VF-Series Wiring Chart (Incoming Power)
35
Performance of 50VF-Series Operators on 1 and 3 Phase, 50 or 60Hz
35
Control Transformer Connections (Non-UPS)
37
Gate Operator Connections (Modular Unit)
37
UPS Backup Power Options
38
DC Power Supply (UPS) Connections
38
AC Power Supply with Hyinverter AC
38
Initial Setup
39
Gate Handing
39
Hydraulic Hose Swap
40
Adjusting the Brake Valves
40
Grounding, Breather Cap Installation & Handing
41
Slidedriver Standard and Slow down Limit Ramps
42
Adjusting the Pressure Relief Valve
43
Modbus RTU in Slidedriver 50VF-Series
44
Emergency Fast Operate (EFO) in Slidedriver 50VF-Series
45
Installing a Push Button Device for Emergency Fast Operate (EFO)
46
Emergency Fast Close Speeds
46
Entrapment Protection
47
Manufacturer's Responsibility
49
Pressure Relief Valve - All Hydraulic Operators
49
Inherent Entrapment Sensor System - Hydraulic Operators (IES)
49
The Inherent Entrapment Sensor (IES)
50
How Software Handles Monitoring External Entrapment Protection Sensors
51
External Entrapment Protection Sensors: What the Installer Needs to Do
51
Table 4: Installer Menu Settings for SENSOR Inputs
53
Supply Power to the Sensors
54
Control Panel Overview
55
Slidedriver Wiring Diagram, D0266 REV B
56
Variable Speed Drive (VFD) Control Box
57
Variable Speed Drive Wiring Diagram, Pre-May 2017
58
Variable Speed Drive Wiring Diagram, May 2017
59
STC Board, Power Supply Board and Display
60
Display & Menu Options
61
Understanding the Display and Keypad
61
Initial Setup
62
Initial Setup Using S.T.A.R.T
63
Menu Mode and the STC Keypad
63
Menu Mode Navigation
64
Run Mode and the STC Keypad
65
Viewing Gate Operator Scrolling Status
65
Stop the Status Display Scrolling
66
Change the Contrast on 7 Segment Displays
66
Display Power Saving Mode
67
Check the Software Version
67
Check Time and Date
67
User Menu
67
Installer Menu
70
Setting the Close Timer
77
Test the Operator
78
STC Inputs & Wiring
79
Overview of the STC and Power Supply Board
80
Integrating with Security Systems and Hynet™ Gateway
81
Smart Touch Controller Inputs
82
STC Terminal Inputs
82
Connecting Accessory Devices
85
User Relays - Programming Procedure
86
Hy8Relay Module Option
88
Bi-Parting & Dual Gate Systems
89
Connecting an Interlocked Pair (Dual Gate)
89
Dual Gate Wiring Connections
90
Dual or Sequenced Gates: Power, Software & Accessory Requirements
91
Programming a Dual Gate (Interlocked Pair)
91
Connecting Sequenced Gates
92
Sequenced Gate: Configuration #1
94
Sequenced Gate: Configuration #2
95
Ehicle D Etector I Nstallation and L Oop L Ayouts
97
Anti-Tailgate Mode (Closing Logic)
97
Tailgate Alert
97
Vehicle Detectors and the Smart Touch Controller
98
Hy5B Installation
98
Test the Vehicle Loop
98
Check the Version of Software
99
Install Hy5B Vehicle Detectors
99
Vehicle Detector and Loop Fault Diagnostics
101
Installing Standard 11-Pin Box Type Vehicle Detectors
104
Loop Layout: One Lane, Bi- or Single-Directional
105
Photo Eye Installation
106
Photo Eyes (Non-Contact) Installation
107
Compatibility
107
Installation
108
Configuration
108
Photo Eye Connections: Smart Touch & Smart DC Controllers
109
Photo Eye Function
109
Retro-Reflective Photo Eye Systems
110
Using Photo Eye Sensors Instead of Vehicle Loops
110
Photo Eye Alignment Feature
112
Installing Gate Edge Sensors
113
Compatibility
114
Installation
114
Edge Sensor Installation Tips
114
Gate Edge Function
115
Troubleshooting
116
System Diagnostic Messages
116
Typical Problems and Troubleshooting Procedures
117
Table 8: Troubleshooting Codes
118
Access the Event Log through the User Menu
129
Electrical Issues
130
AC-Powered Gate Operators
130
Electrical Controls
130
Mechanical Issues
131
Hydraulic Issues
131
General Maintenance
132
Smart Touch Analyze and Retrieve Tool (S.T.A.R.T.)
132
What You Need
132
Installing S.T.A.R.T. Software
132
Ssoftware Maintenance
133
Electrical Controls
133
Clock Battery Replacement
133
Mechnical Controls
134
Stopping the Gate
134
Starting the Gate
134
Mechanical Maintenance
134
Drive Rail
135
Drive Wheel Spring Tension (Adjustment of Manual Release)
136
Grooved Drive Rail
137
Drive Wheel Assembly
138
Hydraulic System Maintenance
139
Brake Valve Adjustments
140
Pressure Relief Valve Adjustments
140
Open Valve
140
Slidedriver Operator Maintenance Schedule
141
Wiring Hysecurity Sensors: Smart Touch
142
Wiring Tips for SENSOR COM Terminal: Smart Touch
143
Menu Mode Navigational Tips
143
Smart Touch: 2 CH Wired Edge with Hy2Nc
144
Smart Touch: Photo Eye Thru Beam (EMX IRB MON)
145
Smart Touch: Photo Eye / Reflective (E3K R10K4)
146
Smart Touch: the Solution, MIM-62 (Multi-Input Module)
147
Smart Touch: Igaze Kit Wiring Diagram
148
Slidedriver Installer Checklist
149
Appendix A - French Translations
151
Specifications
156
Other manuals for HySecurity SlideDriver 50VF2/3
Installation Instructions
10 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the HySecurity SlideDriver 50VF2/3 and is the answer not in the manual?
Ask a question
HySecurity SlideDriver 50VF2/3 Specifications
General
Brand
HySecurity
Model
SlideDriver 50VF2/3
Category
Gate Opener
Language
English
Related product manuals
SlideDriver 50 VF Series
156 pages
HySecurity SlideDriver 40
156 pages
HySecurity SlideDriver 15
156 pages
HySecurity SlideDriver 30F
156 pages
HySecurity SlideSmart DC 15
148 pages
HySecurity SlideSmart DCS 15
148 pages
HySecurity HyNet SFP 4/1
148 pages
HySecurity SwingSmart DC 20
134 pages
HySecurity StrongArmPark DC 10
82 pages
HySecurity StrongArmPark DC 14
82 pages
HySecurity StrongArmPark DCS 14
82 pages
HySecurity Smart Touch
134 pages
Need help?
General
To Next Page
