Incon TS-LLD - Page 8

TOC Page TOC - 6 TS-LLD INSTALLATION GUIDE
Table of Figures & Diagrams
Chapter . Section Page No.
Chapter 2 . Section 3
Figure 2.3-1 CU Internal & Bottom Views, and Relay Box Top View .. 2.3 - 1
Figure 2.3-2 CU Component Location - Internal View ........................ 2.3 - 2
Figure 2.3-3 TS-LLD CU Typical Mounting and Conduit Routing ....... 2.3 - 3
TABLE 2.3 -1 Typical Single Phase Wire Connection List .............. 2.3 - 4
Figure 2.3-4 Typical Single Phase 240 VAC
Pump Relay Box & Control Unit Wiring Diagram ........ 2.3 - 5
Figure 2.3-5 Typical Single Phase 240 VAC
Pump & Control Unit Interface Schematic .................. 2.3 - 6
Figure 2.3-6 Single Phase 240 VAC Multiple Pump & Manifolded
Line w/ Single LSU & CU Interface Schematic .......... 2.3 - 7
Figure 2.3-7 Mechanical Blender Dispensers to
TS-LLD Control Unit Interface Schematic .................. 2.3 - 8
Figure 2.3-8 Three Phase 240 VAC Pump & Control Unit
Interface Schematic .................................................... 2.3 - 9
Figure 2.3-9 Three Phase 240 VAC Supply – Starter – Motor
Control Box – and BigFlo Pump (3 wire)
Interface Schematic to TS-LLD ................................ 2.3 - 10
Figure 2.3-10 Three Phase 240 VAC Supply – Starter – Motor
Control Box – and BigFlo Pump (5 wire)
Interface Schematic to TS-LLD ................................ 2.3 - 11
Figure 2.3-11 Three Phase 240 VAC Supply – Starter & Motor
Control Box – Standard (FE Petro STP)
Interface Schematic to TS-LLD ................................ 2.3 - 12
Figure 2.3-12 Three Phase 240 VAC Supply – FE Petro
Variable Frequency Controller (VFC),
Motor Control Box – and IST Pump
Interface Schematic to TS-LLD................................. 2.3 - 13
Figure 2.3-13 Control Unit Final Assembly ......................................... 2.3 - 14
Chapter 2 . Section 4
Figure 2.4-1 TS-1000 & TS-TGI Layout .............................................. 2.4 - 1
Figure 2.4-2 TS-1000 & TS-TGI – TS-LLD Wiring Diagram ............... 2.4 - 2
Figure 2.4-3 TS-2000 – TS-LLD Line Leak Detector Interface .......... 2.4 - 3
Figure 2.4-4 TS-1001 / 2001 Typical Hardware Layout ...................... 2.4 - 4
Figure 2.4-5 TS-1001 / 2001 LLD
I Wiring Diagram ........................... 2.4 - 5
Chapter 3
Figure 3-1: Control Unit Cover – Component Location ....................... 3 - 2
Chapter 5
LSU Bottom & Side Views ........................................................................ 5 - 2
—
❖
—