Johnson Controls Frick 852 User Manual

RWH ROTARY SCREW COMPRESSOR UNITS
MAINTENANCE
070.620-IOM (DEC 12)
Page 56
Page 4 Unit Serial # ________________ Frick Order No: __________________________________________
P&ID Setpoints
Name _________________ __________ _________________ ____________
Control ____________ ____________ ____________ ____________
Action __________________ ____________ __________________ ____________
Control Point __________________ ____________ __________________ ____________
Device Source ______________ __________ ______________ ____________
Device Channel ____________ ____________ ____________ ____________
Setpoint ____________ ____________ ____________ ____________
Dead Band ____________ ____________ ____________ ____________
Prop. Band ____________ ____________ ____________ ____________
Integral Gain ____________ ____________ ____________ ____________
Communications
Compressor ID ______
Comm 1 Comm 2 Comm 3
Baud Rate _________ Baud Rate __________ Baud Rate ___________
Data Bits _________ Data Bits ____________ Data Bits ____________
Stop Bits _________ Stop Bits ___________ Stop Bits ____________
Parity ____________ Parity ______________ Parity_______________
RS 485 Connection _______ RS 485 Connection _______ RS 485 Connection _______
Protocol __________ Protocol _________ Protocol __________ Use Map File ________
Ethernet
IP Data Naming Data Protocols
Address Type __________ Host Name __________ ModBus TCP ________
IP Address __________ Work Group _________ Ethernet I/P _________
Gateway Address __________ Comments __________ Pronet _____________
Subnet Mask __________
Web Server Port __________
Compressor Operating Log Sheet Starter Operating Log Sheet
Date Average Current
Time Current Phase A
Hour Meter Reading Current Phase B
Equip. Room Temp. Current Phase C
Suction Pressure Full Load Amps
Suction Temperature Output Frequency
Suction Superheat Output Voltage
Discharge Pressure DC Bus Voltage
Discharge Temperature Input Power kW
Corresponding Temperature Actual Speed
Oil Pressure Speed Command
Oil Temperature Ambient Temp F.
Oil Filter Pressure Drop Convert Heatsink Temp. F.
Separator Temperature Baseplate Temp. F.
Slide Valve Position VSD Operating Mode
Volume Ratio (VI) Harmonic Filter Present
Motor Amps / FLA % Harmonic Filter Mode
Capacity Control Setpoint Water Pump Energized
Oil Level Precharge Relay Energized
Oil Added Trigger SCR’s Energized
Seal Leakage (Drops/Min.) DC Inverter Link Current
Evaporator. EWT F. Motor Winding Temp. F.
Evaporator LWT F. Humidistat % RH
Condenser EWT F. Vyper Coolant Temp. F.
Condenser LWT F. Total kWh

Johnson Controls Frick 852 Specifications

General

Brand	Johnson Controls
Model	Frick 852
Category	Compressor
Language	English