KTM 690 LC4 - Periodic Maintenance Schedule

PERIODIC MAINTENANCE SCHEDULE »
30
690 SUPERMOTO / 690 SUPERMOTO PRESTIGE 2007
A clean motorcycle can be checked more quickly which saves money!
1st Service
after
1000 km
(621 miles)
every
5000 km
(3107 miles) or
once a year
every
10000 km
(6214 miles) or
every 2 years
ENGINE
Change engine oil, coarse and fine filter
z z z
Clean oil screens and drain plug magnet
z z z
Renew spark plug
z
Check and adjust valve clearance
z
Check engine fastening bolts for tight fit
z z z
Check all engine bolts accessible from the outside for tight fit
z z z
FUEL INJECTION
Check rubber boots for cracks or leaks
z z
Check fault memory with the KTM diagnosis tool
z z z
Perform a status check of neutral, clutch, 2nd/3rd gear and side stand switch
using the KTM diagnosis tool
z z z
Make sure the fuel hose, SAS hoses and vent hoses are run correctly and
check for damage
z z z
Replace the O-ring on the fuel hose connection and check for leaks
z z z
Check the wiring harness on the throttle body for proper installation
and damage
z z
ADD-ON-PARTS
Check cooling system for leaks and antifreeze protection
z z z
Check radiator fan for proper operation
z z z
Check the exhaust system for leaks and correct suspension and the clamps
for a tight fit
z z z
Check actuating cables for damage, smooth operation, and kink-less arrange-
ment, adjust and lubricate
z z z
Check the oil level in the hydraulic clutch reservoir
z z
Check air filter, renew if necessary, clean air filter box
z z
Check cables for damage and kink-less arrangement
z z z