KTM 690 SMC R User Manual (English)

Other manuals for KTM 690 SMC R

Questions and Answers:

C
carol52Aug 18, 2025
What to do if the KTM 690 SMC R engine doesn't turn over when pressing the starter button?
- V
  Valerie PerryAug 19, 2025
  If the engine doesn't turn over when you press the starter button, there could be several reasons: * It may be due to an operating error, so ensure you are following the correct start procedure. * The battery might be discharged; in this case, recharge the battery and check the quiescent current. * A fuse (1 or 2) could be blown; replace the blown fuses. Remember to set the clock afterwards. * The main fuse might be burned out; replace the main fuse. * There might be no ground connection; check the ground connection.
M
Michael VargasAug 21, 2025
Why does my KTM 690 SMC R Motorcycle engine turn but not start?
- L
  leslierivasAug 21, 2025
  If your KTM Motorcycle engine turns but doesn't start, consider these potential causes: * Ensure you are using the correct start procedure, as it may be due to an operating error. * A fuse (3) might be blown; replace the fuse. * The fuel hose connection might not be properly connected; connect the plug-in connection of the fuel line. * There could be a defect in the fuel injection system; use the KTM diagnostics tool to read out the fault memory. * The air filter could be very dirty; remove and install the air filter. * The fuel screen could be very dirty; change the fuel screen. * The fuel filter could be very dirty; check the fuel pressure.
J
Jennifer DelacruzAug 23, 2025
What to do if my KTM 690 SMC R Motorcycle engine dies while riding?
- R
  ryangarciaAug 23, 2025
  If your KTM Motorcycle engine dies during a journey, it could be due to: * Lack of fuel; refuel the motorcycle. * A blown fuse (1, 2, or 3); replace the fuse.
E
elizabethwellsAug 26, 2025
How to fix KTM 690 SMC R Motorcycle overheating?
- D
  Devin GardnerAug 26, 2025
  If your KTM Motorcycle engine is overheating, consider the following: * Check for leaks in the cooling system and ensure the coolant level is adequate. * Clean the radiator fins if they are dirty. * If there's foam formation in the cooling system, drain and refill/bleed the system. * Replace any buckled or damaged radiator hoses. * Check the thermostat for faults. * Replace fuse 5 if it's blown. * Check the radiator fan system for defects. * Bleed the cooling system to remove any air.
C
Crystal SchultzAug 27, 2025
Why is my KTM 690 SMC R Motorcycle battery discharged?
- H
  Henry DixonAug 28, 2025
  A discharged KTM Motorcycle battery can result from: * Leaving the ignition on when the vehicle is parked; recharge the battery. * The alternator not charging the battery; check the charging voltage and the quiescent current.
T
Tina PerezAug 30, 2025
What does it mean when the ABS warning lamp lights up on my KTM 690 SMC R?
- G
  Garrett HarrisAug 30, 2025
  If the ABS warning lamp illuminates on your KTM Motorcycle, the possible causes are: * The ABS fuse is blown; change the ABS fuses. * There is a large difference in wheel speeds between the front and rear wheels; stop the vehicle, switch off the ignition, and start it again. * There is a malfunction in the ABS; read out the ABS fault memory using the KTM diagnostics tool. * The engine vent hose is bent; route the vent hose without bends or change it if necessary.
D
derekserranoSep 1, 2025
What does it mean if the FI warning lamp (MIL) lights or flashes on my KTM 690 SMC R?
- M
  Michael MurphySep 1, 2025
  If the FI warning lamp (MIL) lights or flashes on your KTM Motorcycle, it indicates a defect in the fuel injection system. Read out the fault memory using the KTM diagnostics tool.
J
Jeanette OneillSep 3, 2025
Why does my KTM 690 SMC R have high oil consumption?
- L
  laravalerieSep 4, 2025
  High oil consumption in your KTM Motorcycle could be due to the engine oil being too thin (low viscosity). Change the engine oil and filter, and clean the oil screens.
A
Ashley RyanSep 6, 2025
Why is the combination instrument display blank on my KTM Motorcycle?
- R
  Rachael SpencerSep 6, 2025
  If the combination instrument display is blank on your KTM Motorcycle, it could be due to a blown fuse (1 or 2). Change the fuses and set the clock.
M
Makayla SmithSep 8, 2025
Why are the headlight and parking light not working on my KTM 690 SMC R Motorcycle?
- C
  Chelsey MendozaSep 8, 2025
  If the headlight and parking light are not functioning on your KTM Motorcycle, it is possible that fuse 6 is blown. Change the fuse.

KTM 690 SMC R Specifications

General

Engine Type	Single-cylinder, 4-stroke
Bore x Stroke	105 mm x 80 mm
Compression Ratio	12.7:1
Starter	Electric starter
Transmission	6-speed
Fuel System	Electronic Fuel Injection
Cooling System	Liquid cooled
Frame	Chromium-Molybdenum steel trellis frame, powder coated
Front Wheel	3.50 x 17"
Rear Wheel	5.00 x 17"
Front Tire	120/70 ZR 17
Rear Tire	160/60 ZR 17
Seat Height	890 mm
Power	55 kW (74 hp)
Torque	73.5 Nm
Front Suspension	WP APEX 48
Rear Suspension	WP APEX with Pro-Lever linkage
Front Brake	Single 320 mm disc, 4-piston caliper
Rear Brake	Single 240 mm disc, 1-piston caliper
ABS	Bosch 9.1 MP (lean angle sensitive)
Fuel Tank Capacity	13.5 liters
Dry Weight	147 kg