Manitou 170 AETJ L - Battery Charging Procedure

CHARGE THE BATTERIES
t
IMPORTANT
t
Always charge the battery in a well-ventilated area, protected from sunlight and rain.
Do not charge the batteries during a lightning storm.
Do not charge the batteries if the electrolyte temperature is over 40°C.
Always remove the battery covers during charging.
Ensure that the battery terminals cannot come into contact with metal objects.
No flames or sparks. Do not smoke near to the batteries during charging.
t
IMPORTANT
t
It is recommended to charge the batteries at the end of each day's use.
Do not interrupt the charging cycle. It is recommended to charge the batteries to 100% to preserve their life.
Check the battery charge level every week when the platform is stored away for a long period. Recharge if necessary.
NOTE: Depending on use, battery life is approximately 5 hours when fully charged.
The charging time to go from 20% to 100% is approximately 10 hours.
- Park the platform.
- Remove the right and left battery covers
1
.
- Connect the electrical plug
2
of the battery charger to a power source.
NOTE: The horn sounds (modulated frequency) when the battery cut-off is in the
ON position.
- Wait until the batteries are fully charged.
- Disconnect the electrical plug
2
.
- Turn the battery cut-off to the ON position.
- Turn the ignition switch to position
.
- Wait for the audible alarm to sound once.
- Check the battery charge level on the multi-function display, eDESCRIPTION OF
THE MULTI-FUNCTION DISPLAY: BATTERY CHARGE LEVEL.
- Put the battery covers
1
back in place.
- Turn the platform off.
BATTERY CHARGER STATUS INDICATOR LAMP
3
(GROUND LEVEL CONTROL PANEL)
Illustration = second version.
- Off: The battery charger is not turned on.
- Steady red light: Initial charging phase.
- Steady yellow light: Batteries 80% charged.
- Steady green light: Batteries fully charged.
- Flashing yellow light: Battery balancing cycle.
- Blinking red light: The battery charger is in alarm mode; refer to maintenance
personnel.
3
2 - 52
2
1
647536 (26/11/2020) 150 AETJ/AETJ 3D - 150 AETJ C/AETJ C 3D - 170 AETJ L