INSTALLATION AND OPERATION MODEL YB8
April 1999/Manning Environmental Inc.
Page A-8
Assembly
Assembling the Model YB8 Sampler
The unit is normally shipped assembled with accessories packed inside the refrigerator.
Refrigerator
There are several things to keep in mind before installing t he refrigerator. T he location is important.
It is best to locate the unit out of direct sunlight and away from heat sources. It is best to locate the
unit at least two inches away from any kind of wall. Ventilation is required from the bottom front
section of the unit. Keep this area open and clear of any obstructions. It is recommended not to use
a power cord to power the unit. It is best if the unit can be plugged directly into the appropriate
power supply outlet. The refrigeration system is equipped with a power supply cord that has a three-
pronged grounded plug. It must be plugged into a mating grounding type receptacle in accordance
with the National Electrical Code and applicable local codes and ordinances. If the circuit does not
have a grounding type receptacle, it is the responsibility and obligation of t he customer t o exchange
the existing receptacle in accordance with the National Electrical Code and applicable local codes an
dordinances. Th ethird ground prong should not under any circumstances, be cut or removed. All
U.L listed refrigerated products are equippedd with this type of plug, except hazardous location
models which are to wired to comply with the National Electrical Code, Article 501-4 for Class I
Divisions 1 and 2
Things to remember about the refrigerator:
A. Allow 24 hours for your refrigerator to reach a new temperature setting.
B. The motor will start and stop often. I t must do t his to maintain t he temperature yo u
select.
C. Keep you refrigerator as level as possible
D. Unplug the refrigerator before working on anything with the electrical system.
E. Exercise caution when sweeping, vacuuming or mopping near the front of the unit.
Damage t o the grill can occur.
F. For all cleaning of the refrigerator, mix 2 tablespoons baking soda into 1 quart warm
water o r use mild soap. D o not use strong cleaners o r scouring powders or pads.
G. Keep all flame or sparks away from flammable material storage refrigerators when
opening the door to remove or store commodities.
H. Disconnect electrical power before removing electrical plug
Unpack the refrigerator by removing the bands at the top and bottom of the refrigerator box and
lifting the box off of the refrigeration unit. Open the refrigerator door and check for various
components that might be inside the refrigerator. I tems are often packed inside t he unit t o minimize
shipping space. Check the items you have received against the packing list. Call Manning
immediately if yo u cannot match the packing list t o the items shipped. M anning strives fo r 100%
accurate shipments, but mistakes do happen, so please call Manning immediately if t here is a
discrepancy.
To Next Page
Loading...