maximal FD100T - III. Introduction for Main Parts of Forklift Truck

5-10t Internal Combustion Counterbalance Forklift Truck Operation & Maintenance Manual
-
16
-
III. Introduction for Main Parts of Forklift Truck
Refer to the following table for main parts of forklift truck.
S/N Name Item
1 Air Filter and Installation Including air filter, air filter support plate, air inlet pipe, and air outlet pipe
2 Battery and Installation Including battery, cross beam, and support bar
3 Radiator and Installation
Including radiator and standby tank, water supply and drain pipes, rubber
gasket, and bolts for radiator
4
Fuel Device and
Installation
Including cover plate assembly, cover plate gasket, air plug, oil quantity
sensor, oil tank cover, oil-water separator, diesel oil filter, and oil delivery
hose
5 Muffler and Installation
Including muffler, front vent pipe, rubber gasket, connecting pipe, vent
pipe, and U-bolt for block plate
6 Electrical System
Mainly including light fittings, instruments, wire harnesses, and electrical
components
7
Drive Axle and
Installation
Mainly including axle housing, transmission, speed differential,
wheel-sided reducer, half shaft, and brake
8 Front Wheel Assembly Including tyre, front wheel rim assembly, and air valve bracket
9 Rear Wheel Assembly Including tyre, and rear-wheel rim assembly
10
Engine and Transmission
Installation
Including drive transmission, engine, transmission bracket, and
transmission support
11 Transmission Control
Including bracket for control rod, pin shaft, rocking arm, and connecting
rod
12
Steering Device and
Installation
Including steering column, universal joint, connecting shaft, steering
wheel, and handle
13
Steering Axle and
Installation
Including steering axle, and steering cylinder