Mec 4907 - Table of Contents

Page ii 1330SE - Operator’s Manual
June 2023
Table of Contents
Section 1 - Introduction . . . . . . . . . . . . . . . . 1
Introduction � � � � � � � � � � � � � � � � � � � � � 1
Section 2 - Safety . . . . . . . . . . . . . . . . . 2
Safety � � � � � � � � � � � � � � � � � � � � � � � 2
Safety Alert Symbols & Fall Protection � � � � � � � � � � � � � � 3
Section 3 - Specications . . . . . . . . . . . . . . . 4
Specications � � � � � � � � � � � � � � � � � � � � � 4
Section 4 - Hazards . . . . . . . . . . . . . . . . . 5
Electrocution Hazard � � � � � � � � � � � � � � � � � � � 5
Energized Conductor Contact Hazard� � � � � � � � � � � � � � � 6
Tip-over Hazards
� � � � � � � � � � � � � � � � � � � � 8
Fall & Collision Hazards
� � � � � � � � � � � � � � � � � � 9
Additional Safety Hazards � � � � � � � � � � � � � � � � � � 10
Section 5 - Controls & Components . . . . . . . . . . . . 11
Component Locations � � � � � � � � � � � � � � � � � � � 11
Upper Controls
� � � � � � � � � � � � � � � � � � � � � 12
Lower Controls� � � � � � � � � � � � � � � � � � � � � 13
Section 6 - Workplace Inspection . . . . . . . . . . . . . 14
Workplace Inspection � � � � � � � � � � � � � � � � � � � 14
Section 7 - Operating Instructions & Functions Test . . . . . . . . 15
Operating Instructions & Functions Test � � � � � � � � � � � � � � 15
Operating Instructions
� � � � � � � � � � � � � � � � � � � 19
Section 8 - Battery Charging . . . . . . . . . . . . . . 25
Battery Charging � � � � � � � � � � � � � � � � � � � � 25
Section 9 - Maintenance. . . . . . . . . . . . . . . . 26
Maintenance � � � � � � � � � � � � � � � � � � � � � 26
Routine Maintenance � � � � � � � � � � � � � � � � � � � 28
Lubrication� � � � � � � � � � � � � � � � � � � � � � 29
Pre-Start Inspection Checklist
� � � � � � � � � � � � � � � � � 30
Frequent Inspection Checklist
� � � � � � � � � � � � � � � � � 31
Maintenance Inspection Report � � � � � � � � � � � � � � � � 32
Section 10 - Warning and Instructional Decals . . . . . . . . . 33
Decals � � � � � � � � � � � � � � � � � � � � � � � 33
Serial Plate � � � � � � � � � � � � � � � � � � � � � 35
Section 11 - Troubleshooting . . . . . . . . . . . . . . 36
Troubleshooting � � � � � � � � � � � � � � � � � � � � 36
Section 12 - Transport and Lifting Instructions . . . . . . . . . 37
Transport and Lifting Instructions � � � � � � � � � � � � � � � � 37