To Next Page

To Previous Page

Section 4

Section 4 – Maintenance and cleaning

• Service & Maintenance of the equipment should only be carried out by Welbilt

(Halesowen) Limited. trained, competent, technicians, abiding by all the relevant

statutory regulations and industry recommendations.

• Before removing the panels from the equipment the mains supply must be

disconnected, either by removal of the plug from the wall socket, or in the

FDVHRIKDUGZLUHGHTXLSPHQWVZLWFKHGR΍DWWKHLVRODWRUΖQERWKFDVHVWKH

HTXLSPHQWPXVWEHORFNHGR΍WRSUHYHQWWKHHTXLSPHQWLQDGYHUWHQWO\EHLQJ

powered up.

• Live testing must be avoided wherever possible, in most cases components can

be tested with a multi-meter or insulation tester. Where live testing becomes

necessary, all possible precautions to prevent injury to the maintenance

technician and other people within the vicinity must be taken.

• In the event of the unit freezing up, disconnect the unit from the mains power

supply and leave the unit to defrost until all the ice in the water bath has

disappeared. Check the plumbing on the unit for leaks, (in the event of a leak call

your service provider). If the unit has no leaks, reconnect the power to the unit

and leave for 2 hours to rebuild the ice bank. Check for normal operation of the

unit. In the event that the unit freezes up a second time or fails to operate as

normal you MUST notify your service provider of a fault with the system.

WARNING:

• Persons performing cleaning/ sanitizing operations MUST be competent and

fully trained in safe methods of use of cleaning/sanitising agents and their

applications.

• Personal protective equipment should always be used.

ȏ )OXVKVDQLWLVLQJVROXWLRQIURPWKHXQLWWKRURXJKO\5HVLGXDOFOHDQLQJȵXLGVRU

chemicals left in the system could create a health hazard.

• Do not use a water jet or steam hose to clean the appliance at any time.

• Regarding the cleaning and sanitising procedures please refer to national/EU

regulations.

• The appliance must be thoroughly sanitised upon installation and before

commissioning.

ȏ )RUUHDVRQVRIK\JLHQHLWLVQHFHVVDU\WKDWWKHV\VWHPEHȵXVKHGWKRURXJKO\

after extended periods without use.

METHOD OF POWER ISOLATION

 6ZLWFKR΍WKHXQLWDWWKHSOXJVRFNHW

2. Remove the plug from the socket.

Multiplex Icecore 10 R290 User Manual

Questions and Answers: