W415-1705 / G / 03.21.19
EN
4
table of contents
1.0 general information 5
1.1 rates and effi ciencies 5
1.2 installation overview 6
1.3 rating plate information 8
1.4 mobile home installation 8
1.5 hardware list 9
2.0 dimensions 10
2.1 BL36-1 10
2.2 BL46 11
3.0 venting requirements 12
3.1 typical venting installation 13
3.2 minimum air terminal location
clearances 15
3.3 vent application fl ow chart 16
3.4 defi nitions 16
3.5 elbow vent length values 16
3.6 horizontal termination 17
3.7 vertical termination 19
3.8 vent shield installation (BL46 only) 21
4.0 rough framing 22
4.1 minimum framing dimensions 23
5.0 venting installation 25
5.1 horizontal installation 26
5.2 vertical installation 26
5.3 using either fl exible or rigid vent
components 27
5.4 using fl exible vent components 27
5.4.1 horizontal air terminal installation 27
5.4.2 vertical air terminal installation 28
5.4.3 appliance vent connection 28
5.5 using rigid vent components 29
5.5.1 horizontal air terminal installation 29
5.5.2 vertical air terminal installation 30
5.5.3 restricting vertical vents 31
5.6 vertical through existing chimney 32
Changes, other than editorial, are denoted by a vertical line in the margin
note:
6.0 electrical information 33
6.1 hard wiring connection 33
6.2 receptacle wiring diagram 33
6.3 electronic wiring diagram 33
6.4 optional wall switch 33
6.5 battery back-up installation 34
6.6 wiring diagram 35
7.0 gas installation 36
8.0 nailing tab installation 36
9.0 operation 37
10.0 finish framing 38
10.1 fl ush 38
10.2 recessed 39
10.3 minimum clearance to combustible
enclosures 40
11.0 finishing 41
11.1 anti condensation switch 41
11.2 control cover installation 41
11.3 installing non-combustible board 42
11.4 minimum combustible mantel
clearances 43
11.5 safety barrier & glass door installation
/ removal 44
11.6 glass media installation 45
11.7 optional blower installation 46
11.8 restricting vertical vents 47
11.9 venturi adjustment 47
11.10 pilot burner adjustment 48
11.11 fl ame characteristics 48
12.0 maintenance 49
12.1 care of glass 49
12.2 annual maintenance 50
12.3 glass / door replacement 50
13.0 replacements 51
13.1 BL36-1 overview 52
13.2 BL36-1 valve train assembly 53
13.3 BL46 overview 54
13.4 BL46 valve train assembly 55
14.0 troubleshooting 56
15.0 warranty 59
f i r e - p a r t s . c o m
To Next Page
Loading...
Need help?
General
