ODES UTVS Raider - Page 113

- 112 -
ITEM
ROUTINE
Whichever
Comes first
INTIAL
EVERY
month
1
3
6
6
12
(mi)
(100)
(500)
(1000)
(2000)
(3000)
hours
5
25
50
100
200
Front brake*
●Check operation/brake pad wear/fluid leakage
●Correct if necessary. Replace pads if worn to the limit
O
O
O
O
O
Rear brake*
●Check operation/brake pad wear/fluid leakage
●Correct if necessary. Replace pads if worn to the limit
O
O
O
O
O
Accelerator pedal*
●Check operation and free play
O
O
O
O
O
Wheels*
●Check balance/damage/ run out
●Repair if necessary
O
O
O
O
Wheel bearings*
●Check bearing assemblies for looseness/damage..
●Replace if damaged.
O
O
O
O
Front and rear
Suspension*
●Check operation and for leakage
●Correct if necessary
O
O
Steering system*
●Check operation and for looseness/Replace if damage
●Check toe-in/Adjust if necessary
O
O
O
O
O
Rear knuckle pivots and
suspension arms*
●Lubricate with lithium-soap-based grease
O
O
O
Drive shaft universal joint*
●Lubricate with lithium-soap-based grease
O
O
O
Engine mount*
●Check for cracks or damage
●Correct bolt tightness
O
O
O
Front and rear axle boots*
●Check operation
●Replace if damage
O
O
Stabilizer bushings*
●Check for cracks or damage
O
O
O
Fittings and fasteners*
●Check all chassis fittings and fasteners
●Correct if necessary
O
O
O
O
O
NOTE:
● Recommended brake fluid: DOT4
● Brake fluid replacement:
● Replace the brake hoses every four years, or if cracked or damaged.
● When disassembling the master cylinder or caliper, replace the brake fluid.
Normally check the brake fluid level and add fluid as required.
● On the inner parts of the master cylinder and caliper, replace the oil seals every two years.