Perkins 4012-46A - Page 75

SEBU8191-01 75
Index Section
Fuel System - Pr
ime .............................................. 60
Fuel System Filter - Replace ................................. 61
Fuel Filter with Water Separator ........................ 61
Fuel System Pr
imary Filter/W ater Separator -
Drain .................................................................... 62
Fuel Tank Water and Sediment - Drain ................. 62
Drain the Wat
er and the Sediment..................... 63
Fuel Storage Tanks ............................................ 63
Fuel Tank ........................................................... 63
Fuel Transf
er Pump (Lift Pump) - Inspect ............. 63
Replacement of the Lift Pump............................ 63
G
General Ha
zard Information .......... .......................... 5
Containing Fluid Spillage ..................................... 6
Fluid Penetration.................................................. 6
Pressure A
ir and Water........................................ 6
General Information............................................... 12
Governor Actuator - Check.................................... 64
H
Hoses and Clamps - Inspect/Replace ................... 64
Replace the Hoses and the Clamps .................. 64
I
Important Safety Information ................................... 2
L
Lifti
ng and Storage ................................................ 19
M
Maintenance Interval Schedule ............................. 40
Main
tenance Section ............................................. 27
Model View Illustrations......................................... 13
4012-46A ........................................................... 13
Mode
l Views .......................................................... 13
Monitoring System................................................. 20
Mounting and Dismounting...................................... 9
O
Operation Section.................................................. 19
Overhaul (Major).................................................... 65
Ma
jor Overhaul Information ............................... 65
Scheduling a Major Overhaul............................. 65
Overhaul (Top End) ............................................... 66
Sc
heduling a Top End Overhaul ........................ 66
Top End Overhaul Information ........................... 66
P
Plate Locations and Film Locations....................... 17
Engine Identi
fication........................................... 17
Serial Number Plate........................................... 18
Product Identification Information .......................... 17
Product Info
rmation Section .................................. 12
R
Radiator - Clean .................................................... 67
Refill Capac
ities..................................................... 27
Cooling System.................................................. 27
Fuel System ....................................................... 27
Lubricati
on System ............................................ 27
S
Safety Messages ..................................................... 5
(1) Unive
rsal Warning .......................................... 5
(2) Hot Coolant..................................................... 5
Safety Section ......................................................... 5
Sensors a
nd Electrical Components ..................... 20
Boost Pressure Sensors .................................... 21
Coolant Temperature Switches .......................... 21
Engine O
il Pressure Switch ............................... 22
Overspeed Sensor ............................................. 22
Sensor Locations ............................................... 20
Speed Se
nsor ........ ............................................ 21
Severe Service Application - Check ...................... 67
Environmental Factors ....................................... 68
Incorr
ect Maintenance Procedures .................... 68
Incorrect Operating Procedures......................... 68
Speed Sensor - Clean/Inspect (Engine Speed Sensor
and Ov
erspeed Sensor)....................................... 68
Engine Speed Sensor........................................ 68
Overspeed Sensor ............................................. 69
Start
ing Motor - Inspect ......................................... 69
Starting the Engine ................................................ 23
Normal Engine Starting Procedure .................... 23
Stop
ping the Engine .............................................. 26
T
Table of Contents..................................................... 3
Tur
bocharger - Inspect .......................................... 70
W
Walk-Around Inspection ........................................ 71
Wa
rranty Information ............................................. 73
Warranty Section ................................................... 73
Water Pump - Inspect............................................ 72
We
lding on Engines with Electronic Controls ........ 12