RADICAL SR1 - Standard Pre-Race;Test Check Sheet

45 QD134-15
9.14 STANDARD PRE-RACE/TEST CHECK SHEET
The below checklist is intended as a guide only. This checklist is an expansion of the prep sheet which is on page 46.
1. Bodywork
Check all bodywork for damage
Check all the lights function
Check the underside of the sidepods, diffuser and front splitter skid blocks
Put the car on a stand
Disarm the fire extinguisher
Drain the fuel and measure the amount
2. Shake Test
Check all corners for play in wheel bearings and rose joints
Check all steering components for play
Check rockers and dampers for play
Check the front diffuser
Fit new tyres if necessary, clean and fit valve caps
3. Data Check (See Data Manual for further information)
Check engine hours and overrevs
Check the data the following:
High water temperature
Oil surge, Low oil pressure
Gearshift decision’s
Charging trace
Full throttle, 4% on idle
Faulty sensors
4/5. Differential and Driveshafts
Inspect and grease the driveshafts
Check the clutch is working correctly
Check the differential has enough grease
Check the chain condition and tension
6/7/8/9. Suspension and Brakes
Clean the corners whilst checking for cracks on the following components:
Uprights, wishbones, nik-links
Chassis
Wishbone pick up points
Wishbone bushes
Clean and lube wheel nuts
Bleed the brakes and clutch
Check the condition of the brake pads
Check the balance bar
Repack the silencer if needed
10. Engine Bay
Clean the engine bay
Check wiring for signs of heat or chaffing
Check all oil pipes
Check all fuel lines
Check engine mounting bolts
Check all hose clamps
Check differential mounting bolts