Home
Rayco
Log Splitter
RG55
Rayco RG55 User Manual
4
of 1
of 1 rating
72 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
RG55R Operation • Service • Maintenance
68
Engine T
roubleshoot
Engine
Use the following information to determine the source and
solution to problems you may encounter related to the engine.
This information can also be found in the K
ubota Engine
Operator’
s Manual that shipped with this machine.
67
69
Table of Contents
Introduction
2
Table of Contents
3
Literature Information
4
Maintenance
4
Maintenance Intervals
4
Safety
4
Foreword
4
Certified Engine Maintenance
5
Machine Description
5
Breakdown of the Serial Number
6
Serial Numbers Location
6
Identification Numbers
7
Dealer Information
7
Important Safety Information
8
Safety Warnings
8
General Hazard Information
9
Personal Protective Equipment
9
Flying Debris
9
Trapped Pressure
10
Asbestos Information
10
Dispose of Waste Properly
10
Pressurized Air and Water
10
Respiratory Protection
11
Containing Fluid Spillage
11
Crushing & Cutting Prevention
11
Burn Prevention
12
Oils
12
Batteries
12
Coolant
12
Fire Extinguisher Location
13
Ether Starting Fluid
13
Fire Extinguisher
13
Lines, Tubes and Hoses
14
Guards (Operator Protection)
14
Electrical Storm Injury Prevention
14
Other Guards
14
Safety Decals
14
Operation
15
Before Starting Engine
15
Engine Starting
15
Visibility Information
15
Slope Operation
16
Equipment Lowering with Engine Stopped
17
LOCK-Out / Tag-Out Guidelines
17
Tag out Procedure
17
Work Tool Options - Attachments
17
Removal Procedure
18
Parking
18
While Servicing and Performing Maintenance on the Machine
18
Pre-Transportation Checks
18
Before Towing and on the Road
19
Loading Your Combination
19
Slow down When Towing
19
Towing Equipment Requirements
20
Emergency Brake Cable/Chain
20
Safety Chains
20
Your Tow Vehicle
20
Secure the Load
21
Unloading the Machine from the Rayco Trailer
21
Operation
22
Remote Storage
24
Command Cut
25
Remote Overview
25
Starting the Machine
25
Replacing the Batteries
26
Emergency Stop
26
Cutter Wheel Engagement
26
Remote Time out
26
Blade Transition for Transporting
28
Transporting in Freewheel Mode
29
Disable the Wheel Motors
29
Re-Engage the Wheel Motors
29
Dual Wheels
29
Start-Up
30
Pre-Starting Inspection
30
Rear Blade Operation
30
Starting the Engine
30
Starting with Jumper Cables
31
Removing Stumps
32
Stump Removal Procedure
33
Prepare the Machine at the Stump
33
Remove the Roots
33
Repeat STEP 4 Consecutively
33
Stopping the Machine
34
Machine Storage
34
Preparing for Storage
34
Engine Stopping
34
Transporting the Machine
35
Maintenance
36
Engine Identification
37
Engine Oil Level
41
Engine Oil Filter
41
Fuel Filter
42
Draining the Fuel Tank
42
Fuel Tank - Check Level, Fill & Drain
42
Air Cleaner
43
Radiator / Coolant
43
Flush & Refill
44
Cutting Wheel & Teeth
44
Rayco Teeth
44
Changing Teeth
45
Hydraulic Oil
46
Cutter Wheel Bearings Lubricate
46
Tooth Sharpening Guidelines
46
Sharpening Teeth
46
Changing the Hydraulic Oil
47
Start-Up Procedure
47
Drain the Oil
47
Re-Filling the Hydraulic Oil Tank
47
Clutch Spider Coupler
48
Parts / Tool List
48
Lubricate
50
Slewing Ring Check
50
Cutting Wheel Belt - Check & Adjust Tension
50
Smart Tension App
51
PTO Clutch Brake Air Gap
52
Parts that DO NOT Require Maintenance
52
Adjustment for Wear
52
Terminals
52
Steer Wheel Pivot Lubricate
53
Cutter Wheel Gear Box
53
Brakes
53
Drain
53
39670 Main Wiring Schematic
54
Lubricating Grease
56
Cold Weather Lubricants
56
Specifications
56
Engine Fuel
57
Hydraulic Oil (Petroleum-Mineral Base)
57
Rayco Lubrication & Fluid Specifications
57
Engine Oil
57
Hydraulic Schematic 805921
58
Hydraulic Hose Kit 805921H Rev B
60
Hydraulic Adapter Kit 805921A
61
Fuel System Assembly 38605 Rev B
62
Coolant Maintenance
66
Make Proper Antifreeze Additions
66
Coolant / Antifreeze Recommendations
66
Rayco Coolant Specifications
66
Troubleshoot
68
Machine Specs
69
Cutting Wheel
69
Service Parts
70
General Outline
71
Unapproved Service Modification
71
Individual Components
71
Warranty
71
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Rayco RG55 and is the answer not in the manual?
Ask a question
Rayco RG55 Specifications
General
Brand
Rayco
Model
RG55
Category
Log Splitter
Language
English
Related product manuals
Rayco RG55R
72 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
