Regency P33-LP4 - User Manual

FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4
918-520b
MODELS: P33-NG4 Natural Gas P33-LP4 Propane
10/31/11
WARNING:
If the information in these instructions are not followed exactly,
a fi re or explosion may result causing property damage,
personal injury or loss of life.
FOR YOUR SAFETY
Do not store or use gasoline or other fl ammable vapors and
liquids in the vicinity of this or any other appliance.
Installation and service must be performed by a qualifi ed
installer, service agency or the gas supplier.
FOR YOUR SAFETY
What to do if you smell gas:
 Do not try to light any appliance
 Do not touch any electrical switch:
do not use any phone in your
building.
 Immediately call your gas supplier
from a neighbour's phone. Follow
the gas supplier's instructions.
 If you cannot reach your gas
supplier, call the fi re department.
Tested by:
Installer: Please complete the details on the back cover
and leave this manual with the homeowner.
Homeowner: Please keep these instructions for future reference.
www.regency-fi re.com
Owners &
Installation Manual
P33-4 Zero Clearance
Direct Vent Gas Fireplace

Summary

Safety Label

Safety Label

Copy of the safety label contents for review.

Requirements

Important Message

Key instructions and warnings before starting installation.

General Safety Information

General safety guidelines and code compliance for installation.

Installation

Installation Checklist

A step-by-step guide to ensure all installation requirements are met.

Locating Your Fireplace

Guidelines for selecting the optimal location for the fireplace installation.

Unit Dimensions

Key physical measurements and specifications of the fireplace unit.

Clearances

Minimum required air space around the unit for safe operation.

Combustible Mantels

Clearance requirements for combustible materials used as mantels.

Mantel Leg Clearances

Specific clearance rules for mantel legs with different front configurations.

Framing and Finishing

Procedures for framing the fireplace enclosure and finishing the surround.

Venting Introduction

Guidelines and information for proper venting system installation.

Exterior Vent Termination Locations

Specifies locations where vent terminals can and cannot be installed.

Rigid Pipe Venting Systems

Information and components for installing rigid venting pipes.

Rigid Pipe Cross Reference Chart

Comparison of rigid pipe components from different manufacturers.

Rigid Pipe Venting Arrangements

Diagrams showing allowable vertical termination configurations with rigid pipe.

Horizontal Venting Arrangements

Guidelines for horizontal venting using 90° and 45° elbows.

Vertical Termination with Co-Linear Flex System

Instructions for vertical termination using a co-linear flex system.

Unit Installation with Horizontal Termination

Step-by-step guide for installing the unit with horizontal venting.

Unit Installation with Vertical Termination

Step-by-step guide for installing the unit with vertical venting.

NG to LP Conversion

Instructions for converting the fireplace from Natural Gas to Propane.

Installation of the DC Sparker

Guide for installing the DC sparker component.

Contemporary Faceplate Installation

Steps for installing the optional contemporary faceplate.

Installing the Optional Fan

Guide for installing the optional fan and blower.

Optional Remote Control

Instructions for installing the optional remote control system.

Optional Wall Thermostat

Instructions for installing the optional wall thermostat.

Optional Wall Switch

Instructions for installing the optional wall switch.

Wiring Diagrams

Diagrams illustrating electrical connections for the fireplace.

Operating Instructions

Lighting Procedure

Step-by-step guide for lighting the pilot and main burner.

Shutdown Procedure

Instructions for safely turning off the fireplace burner and pilot.

First Fire

Guidance for the initial operation and paint curing process.

Aeration Adjustment

How to adjust air shutters for optimal flame appearance.

Normal Operating Sounds

Explains typical sounds produced by the gas appliance during operation.

Maintenance

General Vent Maintenance

Semi-annual inspection and cleaning of the venting system.

Log Replacement

Procedure for safely replacing fireplace logs.

Thermopile;Thermocouple

Steps for inspecting, removing, and reinstalling these components.

Door Glass

Information on cleaning, replacing, and handling the fireplace glass.

Removing and Installing Valve

Procedures for removing and installing the gas control valve.

Parts List

Main Assembly

List of primary components for the fireplace unit.

Burner & Log Assembly

Components related to the burner, logs, and their support.

Flush Front & Louvers

Parts list for flush front configurations and louvers.

Contemporary Faceplate

Components specific to the contemporary faceplate installation.

Warranty

Warranty Information

Comprehensive explanation of the product's limited lifetime warranty coverage.

Regency P33-LP4 Specifications

General

Brand	Regency
Model	P33-LP4
Category	Indoor Fireplace
Language	English