SPIDER ILD02 EFI - Troubleshooting Power and Mowing Unit; Engine Power and Smoke Issues

Operation Manual – Spider ILD02 EFI
49 / 55
rev. 01-01-02-2021
Engine doesn't
have enough
power
Works on both
cylinders
Polluted air filter
Clean/replace the air filter
Cylinders don’t have enough
compression
Bad fuel
Replace fuel, natural 95 only
Only one cylinder
is working
Loosened rocker arm, detached
lifting rod valves
Reassemble and re-set valve
clearances
Bad spark plug
Clean/replace spark plug
Broken ignition coil
Replace ignition coil
Engine smokes
excessively
Black smoke
Heavily polluted air filter
Clean/replace air filter
White smoke
Too much oil in the engine
Check oil level in the engine,
remove excess
Bad quality or wrong fuel
Replace fuel, natural 95 only
Mower was in servicing position
Temporary problem, not a real
problem
Mowing unit faults
Fault
Probable cause
Solution
Mowing unit
can't be
turned on
Clutch engages and immediately
disengages (control LED turns on
but immediately turns off again)
Electromagnetic clutch
broken
is
Replace
clutch
electromagnetic
Clutch does not engage
Clutch connector
loosened
is
Check
cabling
the
connector and
Clutch engages
Broken V-belt B 1160
Replace V belt
Leaves unmown grass behind, only one blade
is turning
Broken V-belt XPB 2410
Replace V-belt