At operating hours
1.000
2.000
4.000
5.000
7.000
8.000
11.000
13.000
14.000
Carried
out
Hood
Battery hood: check that it is working correctly and check the resistance of the gas
spring that supports the hood
Rear load bed hood: check that it is working correctly and check the resistance of
the gas spring that supports the hood (for LTX-T only)
Electrical system
Battery: check the battery condition and that it is correctly mounted
Battery: check the condition of the cables and sockets
Battery: check the acid density and check that the battery is not damaged
Battery: service the battery according to the manufacturer's instructions
On-board charger (if present): clean
On-board charger (if present): check that it is operating correctly
Truck cables and connectors: check the condition and position
Electrical components: clean
Indicator lights and alarms: check for and then resolve any issues
Lighting: check that the lights, direction indicators and headlights operate correctly
(if present)
Test the insulation between the chassis and the electric motors
Test the insulation between the chassis and the electronic control
Check the insulation between the chassis and the battery poles
On-board charger (if present): earthing and isolation circuit tests
Hydraulic system
Pump unit: check the general condition
Pump unit: check the wear of the lifting motor brushes and inductor
Hydraulic system: check the oil level
Hydraulic system: check for any leakage from cylinders and hydraulic fittings
Hydraulic system: check the condition of the pipe lines
Hydraulic system: grease the lift mast profiles
Operator elevating platform (if present)
Platform chain: check the chain adjustment and maintenance (clean, adjust, grease)
▲
Platform: check the mounting, condition and operation
Maintenance
5
Maintenance - 1000 hours
192 45878043344 EN - 11/2021 - 12
To Next Page
