600H, 750, 750H, 750HH, 825, 900, 900H, USER MANUAL SECTION 3
44
3.3 LUBRICATING GUIDE - COMPRESSOR
3.4 APPLICATION GUIDE
Refer to Figure 3-1. Sullair Air Compressors are
supplied with Sullair AWF which is heavy duty multi-
viscosity, all weather fluid. Sullair AWF also allows
an extended change interval. The fluids in Section
3.3 Lubrication Guide – Compressor can be used.
Any of these oils are suitable under conditions where
severe oil oxidations can occur. Water must be
drained from the receiver tank periodically.
In high ambient temperature and high humidity
conditions, condensed moisture may emulsify with
the oil forming a “milky” color. ATF or SAE 10W is
especially prone to this condition. The fluid should be
Table 3-7: Engine Specifications
Engine 825 900 900H
Make Volvo Volvo Volvo
Type TAD 764VE Tier 4i/Stage 3B AD 764VE Tier 4i/Stage 3B AD 764VE Tier 4i/Stage 3B
Rated Speed 1800 RPM 1800 RPM 1800 RPM
Horsepower, SAE 307 HP (225 kW) 307 HP (225 kW) 307 HP (225 kW)
Cylinders 6 6 6
Cycles 4 4 4
Bore x Stroke 4.25 x 5.12 in (108 x 130 mm) 4.25 x 5.12 in (108 x 130 mm) 4.25 x 5.12 in (108 x 130 mm)
Displacement 436 cu. in (7.15 liters) 436 cu. in (7.15 liters) 436 cu. in (7.15 liters)
Type of Motor Oil
See Engine Operator’s
Manual
See Engine Operator’s
Manual
See Engine Operator’s
Manual
Fuel Tank Capacity 115 U.S. gallons (435 liters) 115 U.S. gallons (435 liters) 115 U.S. gallons (435 liters)
DEF Tank Capacity 5.3 U.S. gallons (20 liters) 5.3 U.S. gallons (20 liters) 5.3 U.S. gallons (20 liters)
Engine Cooling System
Capacity
6 U.S. gallons (22.7 liters) 6 U.S. gallons (22.7 liters) 6 U.S. gallons (22.7 liters)
Idle Speed 1400 RPM 1400 RPM 1400 RPM
Table 3-8: Trailer Specifications
Trailer: DTQ DWQ
Track Width 77 in (1956 mm) 79.5 in (2019 mm)
Tire Size (Load Range) ST 235/80 R16 (E) ST 235/80 R16 (E)
Tire Pressure 75 psig (5.2 bar) 75 psig (5.2 bar)
Wheel Size 16 x 6 16 x 6
Wheel Bolt/Lugnut Torque 80 to 90 ft. lbs (108.5 to 12.0 Nm) 80 to 90 ft. lbs (108.5 to 12.0 Nm)
Fluid Type Change Period, Hours Ambient Temperature Range °F (°C)
Sullair AWF (I) 1500 -20 to 120 (-29 to 49)
D-A Torque Fluid 300 10 to 110 (-12 to 43)
SAE 10W DSE, SF, SG, CD 300 0 to 100 (-18 to 38)
MIL-L-2104E 10W 300 0 to 100 (-18 to 38)
(I) Sullair part numbers for multi-viscosity lubricants are 250030-757 (5gallons/18.9 liters), 250030-758 (55 gallons,208
liter drum)
To Next Page
Loading...
