6-11
.... Apply oil.
.... Apply grease.
....Apply water resistant grease EP2 or equivalent grease.
No.
ITEM
LUBRI-
CANT
FREQUENCY COMMENTS
1 Clutch cable
Pre-race and
between every race
Run oil through cables until it exits the
lower end. Lube the cable ends where
they pivot.
2 Clutch lever pivot
3
Throttle grip and
throttle case
Pre-race
Lightly grease the inside of throttle
cable spool. Keep free from dirt.
4 Throttle cables
5 Brake pedal pivot
Every 1 race/
More often according
to conditions
Grease the brake pedal pivot.
6 Swingarm pivot
Every 3 races/
More often according
to conditions
Clean and pack the bearings.
Keep seals fresh.
Grease the seals.
7
Rear suspension
pivots
Every 1 race/
More often according
to conditions
Clean and pack the bearings.
Keep seals fresh.
Grease the seals.
8
Steering stem
bearings
Every 5 races/
More often according
to conditions
Clean and pack the bearings.
Keep seals fresh.
9
Kick starter lever
pivot
Pre-race Grease the kick starter lever pivot.
0 Choke shaft Pre-race Lightly oil the choke shaft.
A Drive chain
Pre-race and
between every race
Keep chain thoroughly lobed at all
times. Always check wear and
alignment.
B
Cushion lever dust
seals
Every 1 race/
More often according
to conditions
Grease the seals.
C
Front and rear
wheels
Every 1 race/
More often according
to conditions
Grease the bearing and seals.
To Next Page
Loading...
