Suzuki SV650A - Sv650 K7;Sk7;Ak7;Sak7 (07-Model; Contents

2 SV650K7/SK7/AK7/SAK7 (’07-MODEL)
SV650K7/SK7/AK7/SAK7 (’07-MODEL)
CONTENTS
TP SENSOR ADJUSTMENT .................................................................. 61
THROTTLE VALVE SYNCHRONIZATION ............................................ 62
ISC VALVE ............................................................................................. 64
ISC VALVE PRE-SET............................................................................. 65
IGNITION SYSTEM.......................................................................................... 66
INSPECTION .......................................................................................... 66
INTRODUCTION OF ABS (For SV650A/SA).................................................. 68
CAUTIONS IN SERVICING ............................................................................. 72
ABS COMPONENTS ....................................................................................... 75
ABS COMPONENTS LOCATION .......................................................... 75
ABS COUPLER CONNECTION DIAGRAM........................................... 76
ABS WIRING DIAGRAM ........................................................................ 77
ABS UNIT SYSTEM DIAGRAM ............................................................. 78
ABS TROUBLESHOOTING ............................................................................ 79
TROUBLESHOOTING PROCEDURE.................................................... 80
DTC (Diagnostic Trouble Code) OUTPUT ........................................... 89
DTC DELETING AND ABS OPERATION CHECK ................................ 91
USE OF SDS DIAGNOSTIC PROCEDURES......................................... 94
USE OF SDS DIAGNOSIS RESET PROCEDURE ................................ 95
DTC TABLE OF ABS ............................................................................. 101
DTC TROUBLESHOOTING ................................................................... 102
ABS COMPONENT REMOVAL, INSPECTION AND INSTALLATION .......... 119
WIRING HARNESS, CABLE, HOSE ROUTING
AND SENSOR INSTALLATION ...................................................................... 129
THROTTLE BODY INSTALLATION................................................................ 146
REAR FENDER INSTALLATION .................................................................... 147
HEAT SHIELD INSTALLATION ...................................................................... 148
IGNITION COIL INSTALLATION..................................................................... 149
EMISSION CONTROL SYSTEM ..................................................................... 150
EXHAUST EMISSION CONTROL SYSTEM (PAIR SYSTEM) .............. 150
PAIR (AIR SUPPLY) SYSTEM INSPECTION ................................................. 151
HEATED OXYGEN SENSOR (HO2S) INSPECTION
(For E-02, 19, 24, 33)....................................................................................... 151
SPECIAL TOOLS............................................................................................. 152
TIGHTENING TORQUE ................................................................................... 152
SERVICE DATA (SV650/S) ............................................................................. 153
SERVICE DATA (SV650A/SA) ........................................................................ 165
WIRING DIAGRAM ........................................................................................... 177
SAMPLE