102
MAINTENANCE
Daily Inspection (Every 10 Hours)
Inspecting the Fuel Level
WARNING
Never jump off the machine. Use the
steps and handrails when climbing
on and off the machine, and always
support your body at three points with
your hands and feet.
Do not smoke or permit open
flames while fueling or near fueling
operations.
Stop the engine in a well-ventilated
place when supplying fuel.
Clean up spilled fuel immediately.
Do not fill the fuel tank to capacity.
Allow room for expansion.
Tighten the fuel filler cap securely.
1. Check the fuel level using the fuel gauge
(1).
F: full
E: empty
2. If the level is low, supply fuel from the fuel
port (3) while watching the fuel gauge (2).
Refer to page 42 “Fuel Filler Cap”.
Inspecting the Water Separator
and the Fuel Filters
Water Separator
1. Turn the starter switch to the ON
position.
2. Inspect the water separator warning lamp
(7).
3. If the warning lamp starts flashing, drain
the water.
Pre Fuel Filter, Main Fuel Filter
1. Open the side cover.
2. Check for water in the pre-fuel filter and
the main fuel filter.
If there is water, the float (red ring) goes
up. Be sure to drain water before the float
goes up to the element.
3. Loose the vent plug (6) and then the drain
plug (5) to discharge water accumulated
inside.
4. After drainage of water, tighten each plug
and bleed air from the fuel system.
Refer to page 135 “Bleeding the Air from
the Fuel System”.
To Next Page
Loading...