Tornado 99680 - Programmed Maintenance; Recommended Brushes

18
INTERVENTION DAILY 20 HOURS * 200 HOURS * 1000 HOURS *
RECOVERY TANK CLEANING •
SUCTION FILTER CLEANING •
SOLUTION TANK FILTER CLEANING •
BRUSH CLEANING •
BRUSH DISASSEMBLY •
SQUEEGEE CLEANING •
FRONT SQUEEGEE RUBBER REPLACEMENT •
REAR SQUEEGEE RUBBER REPLACEMENT •
SPLASH GUARD RUBBER REPLACEMENT •
CHECK SQUEEGEE ADJUSTMENT •
SQUEEGEE HOSE CLEANING •
SOLUTION TANK CLEANING •
CHECK BATTERIES ELECTROLYTE •
BRUSH MOTOR CHECK •
SUCTION MOTOR CHECK •
CHECK BRUSH BASE GROUP •
SCREW TIGHTENING •
* The hours refer to the ones indicated on the display (see under paragraph ”HOUR METER").
RECOMMENDED BRUSH
Brushmustbechosendependingontypeofooranddirttoberemoved.Theemployedmaterialandthebristlediameteraretheele-
ments that distinguish different types of brush.
MATERIAL CHARACTERISTICS
PPL (Polypropylene) Good wear resistance. Maintains a characteristic with hot water up to 140°F (60°C). It is not hygroscopic.
NYLON Excellent wear resistance, even with hot water over 60°C. It is hygroscopic. It looses its physical characteristics over time.
TYNEXNylonbristleswithgrainsofabrasivematerial.Usewithcautioninordernottomarktheoororruinthepolishing.
BRISTLESTHICKNESSThickerbristlesaremorerigidandmustbeusedonsmoothoororoorwithsmalljoints.Onirregular
oorswithdeepjointsorrelieves,itisrecommendedtousesofterbristleswhichpenetratemoreeasilyanddeeper.Pleasebeaware
that when brush bristles are worn out and therefore too small, they become rigid and unable to penetrate and clean deeper. This may
also happen with thicker bristles creating brush vibration.
PAD HOLDER It is equipped with anchor points that permit the locking of the abrasive pad. The pad is recommended to clean
smoothoors.
CODE QTY DESCRIPTION USE
48902010 1 Brush PPL 0.3 Irregularoorswithlargejoints.
48902020 1 Brush PPL 0.7 Smoothoors withsmalljointsandpersistentdirt.
48902030 1 Brush PPL 0.9 Smoothoors withsmalljointsandpersistentdirt.
48902040 1 Brush TYNEX Floors of resistant material and particularly dirty.
48902050 1 Brush PPL 0.6 Normaloors.
48902060 1 Brush 5-mix Foralltypesofoors.
48802010 1 Pad holder + center lock green For pads of 20”, for smooth surfaces cleaning.