3
DANGER! Electrical wiring should be performed with extreme caution and in compliance with local,
state, and national electrical code NEC/ANSI/NFPA 70, NFPA 30, and NFPA 30A, as appropriate for the
intended use of the pump. Threaded rigid conduit, sealed ttings, and conductor seal should be used
where applicable. The pump must be properly grounded. If installing in deviation of this manual, a licensed
electrician must perform the installation. Improper installation or use of this product will result in serious
bodily injury or death!
DANGER! To ensure safe and proper operation of your equipment, it is critical to read and adhere to all of
the following safety warnings and precautions. Failure to follow instructions below, improper installation, or
use of this product, will cause serious bodily injury or death!
• NEVER smoke near the pump, or use the pump near open ames when pumping a ammable liquid!
Fire can result!
• This product shall not be used to transfer uids into any type of aircraft.
WARNING! Threaded pipe joints and connections should be sealed with the appropriate sealant or sealant
tape to minimize the possibility of leaks. Leaking fuel may cause the potential for re and explosion.
CAUTION! The pump motor is equipped with electronic protection from thermal overload protection; if
overheated, the motor will shut off. If this happens, you must turn off the pump switch to reset this safety
feature, and turn the pump back on when it has cooled to continue use. The pump will not restart until
properly cooled.
DANGER! To minimize static electricity build up and possible explosion, use only static wire conductive
hose when pumping ammable uids, and keep the ll nozzle in contact with the container being lled
during the lling process. Spark / static discharge will cause explosions.
DANGER! Emphasizes an area in which personal injury or even death will result from failure to follow
instructions properly. Mechanical damage may also occur.
WARNING! Emphasizes an area in which personal injury or even death may result from failure to follow
instructions properly. Mechanical damage may also occur.
IMPORTANT!
These boxes contain information that illustrates a point that may save time, or be key to
proper operation, or claries a step.
Safety Information
CAUTION! Failure to observe a “Caution” may cause damage to the equipment.
About This Manual
From initial concept and design through its nal production, your Fill-Rite
®
pump is built to give you years of trouble-free
use. To ensure it provides that service, and to avoid injury or death, it is critical that you read this entire manual prior to
attempting to install or operate your new pump. Become familiar with the terms and diagrams, and pay close attention
to the highlighted areas with the following labels:
To Next Page
Loading...
Need help?
General
