Volvo Penta D16 - Major Components

156 pages

Save Page as PDF

To Next Page

To Previous Page

Major Components

1 Post-EATS temperature-sensor

2 Post-EATS NOx-sensor

3 AUS/DEF Injector

4 Pre-EATS NOx-sensor

5 Pre-EATS temperature-sensor

6 QLT sensor

7 AUS/DEF Tank

8 Pre-EATS temperature-sensor

9 SCR - muffler

Presentation

Main Page

Table of Contents3
Foreword6
Safety Information7
Maneuvering15
Introduction17
About this Manual17
Warranty18
Your New Boat18
Running in the Engine19
Fuel, Oils and Coolant19
Maintenance and Replacement Parts19
Excessive Strain on a Product and Components20
Volvo Penta EVC System, Integrity and Modification20
Installation and Use of Volvo Penta External Helm20
Recording Engine Data21
Certified Engines22
Volvo Penta Dealer Network23
Volvo Penta Action Service23
Presentation24
EATS (Exhaust Aftertreatment System)24
Major Components26
Operation29
Instruments and Controls31
Ignition Lock31
E-Key Panel31
Ignition Switch32
Control Panels33
Start/Stop Panel33
Station Panel33
Cruise Control Panel34
Docking Panel34
Synchronization Panel36
Powertrim Panel36
Gauges37
Displays38
Information Display38
4" Display39
7" Display46
Alarm Handling Display53
Glass Cockpit Display54
Shutdown Module (SDM)56
Powertrim57
Trim Ranges57
Trim Controls58
Maneuvering59
Controls61
Top Mounted Control61
Disengaging the Shift Function63
Adjusting the Friction Brake63
Features64
Lowspeed64
Cruise Control66
Optional67
Battery Management System67
Local Control67
Battery Management Display68
Propeller Shaft Brake71
Power Take-Off71
Volvo Penta Interceptor System72
Operation73
Easy Connect Interface75
Volvo Penta Easy Connect75
Starting76
Before Starting76
Starting the Engine77
Helm Stations77
Read the Instruments and Warm the Engine up78
Operation79
Reading the Instruments79
Alarms79
Maneuvering80
Switch IMO Tier II/III81
Helm Stations82
Station Handling for Type Approved Installation83
Transfer under Way83
Cruising Speed84
Engine Synchronization Disable84
Engine Shutdown85
Before Engine Shutdown85
Stop the Engine85
Ignition Auto off86
Auxiliary Stop86
After Engine Shutdown87
Operation Break88
Cold Weather Precautions88
Fault Handling89
Alarm Handling89
Acknowledge Message90
Fault Tracing91
Fault Code Register93
In Case of Emergency105
Starting Using Auxiliary Batteries105
Maintenance Schedule106
Maintenance107
Orientation108
Engine, General110
Drive Belt, Check and Change110
Lubrication System112
Oil Level, Checking and Topping up112
Oil Filter/By-Pass Filter, Replace113
Switchable Oil Filters114
Fuel System115
Engine Fuel Filter Replacement116
Fuel System, Bleeding118
Fuel Pre-Filter119
Freshwater System120
Coolant Level, Checking and Topping up121
Coolant, Draining122
Freshwater System, Flushing123
Seawater System124
Seawater System, Draining124
Impeller, Check and Change125
Seawater Filter, Check and Cleaning125
Intake Manifold, Checking the Drain Hole126
Electrical System127
Main Switch127
Electrical Connections127
Battery128
Electrical Installations130
Electrical Welding131
Storage132
Bringing out of Storage133
Calibration and Settings134
Settings Menu134
My View134
Neutral Beep134
Information Beep135
Trip Reset135
Depth Alarm135
Display Contrast137
Side Selection137
Units137
Language138
EVC Info138
Fuel Tank139
Technical Data142
Lubrication System142
Viscosity143
Coolant, Mixing147
Identification Numbers149
Index153

Volvo Penta D16 - Major Components

Table of Contents

Related product manuals