Weber 300 - Gas System and Cylinder Management; Safe Handling of LP Gas Cylinders

WWW.WEBER.COM
®
23
GAS INSTRUCTIONS
4"'&)"/%-*/(5*14'03-*26*%1301"/&("4$:-*/%&34
r-JRVJE1SPQBOF-1HBTJTBQFUSPMFVNQSPEVDUBTBSFHBTPMJOFBOEOBUVSBMHBT-1
gas is a gas at regular temperatures and pressures. Under moderate pressure, inside
a cylinder, LP gas is a liquid. As the pressure is released, the liquid readily vaporizes
and becomes gas.
r-1HBTIBTBOPEPSTJNJMBSUPOBUVSBMHBT:PVTIPVMECFBXBSFPGUIJTPEPS
r-1HBTJTIFBWJFSUIBOBJS-FBLJOH-1HBTNBZDPMMFDUJOMPXBSFBTBOEQSFWFOU
dispersion.
r5PGJMMUBLFUIF-1DZMJOEFSUPBHBTQSPQBOFEFBMFSPSMPPLVQiHBTQSPQBOFuJOUIF
phone book for other sources of LP gas.
8"3/*/(8FSFDPNNFOEUIBUZPVS-1DZMJOEFSCFGJMMFE
BUBOBVUIPSJ[FE-1HBTEFBMFSCZBRVBMJGJFEBUUFOEBOU
XIPGJMMTUIFUBOLCZXFJHIU*.1301&3'*--*/(*4
%"/(&3064
r"JSNVTUCFSFNPWFEGSPNBOFX-1DZMJOEFSCFGPSFUIFJOJUJBMGJMMJOH:PVS-1EFBMFSJT
equipped to do this.
r5IF-1DZMJOEFSNVTUCFJOTUBMMFEUSBOTQPSUFEBOETUPSFEJOBOVQSJHIUQPTJUJPO-1
cylinders should not be dropped or handled roughly.
r/FWFSTUPSFPSUSBOTQPSUUIF-1DZMJOEFSXIFSFUFNQFSBUVSFTDBOSFBDI'UPP
hot to hold by hand. (For example: do not leave the LP cylinder in a car on a hot day.)
Note: A refill will last about 18–20 hours of cooking time at normal use. You do not have
to run out before you refill.
r5SFBUiFNQUZu-1DZMJOEFSTXJUIUIFTBNFDBSFBTXIFOGVMM&WFOXIFOUIF-1UBOL
is empty of liquid, there still may be gas pressure in the cylinder. Always close the
cylinder valve before disconnecting.
$"65*0/1MBDFEVTUDBQPODZMJOEFSWBMWFPVUMFUXIFOFWFS
UIFDZMJOEFSJTOPUJOVTF0OMZJOTUBMMUIFUZQFPGEVTUDBQ
POUIFDZMJOEFSWBMWFPVUMFUUIBUJTQSPWJEFEXJUIUIFDZMJOEFS
WBMWF0UIFSUZQFTPGDBQTPSQMVHTNBZSFTVMUJOMFBLBHFPG
QSPQBOF
r%POPUVTFBEBNBHFE-1DZMJOEFS"EFOUFEPSSVTUZ-1DZMJOEFSPSBO-1DZMJOEFS
with a damaged valve may be hazardous and should be replaced with a new one
immediately.
-JRVJE1SPQBOF-1$ZMJOEFST
r5IFKPJOUXIFSFUIFIPTFDPOOFDUTUPUIF-1DZMJOEFSNVTUCFMFBLUFTUFEFBDIUJNF
the LP cylinder is reconnected. For example, test each time the LP cylinder is refilled.
r#FTVSFUIFSFHVMBUPSJTNPVOUFEXJUIUIFTNBMMWFOUIPMFQPJOUFEEPXOXBSETPUIBUJU
will not collect water. This vent should be free of dirt, grease, bugs, etc.
r5IFHBTDPOOFDUJPOTTVQQMJFEXJUIZPVS8FCFS
®
gas barbecue have been designed
and tested to meet 100% CSA and ANSI requirements.
8"3/*/(3FQMBDFNFOU-1UBOLTNVTUNBUDIUIFSFHVMBUPS
DPOOFDUJPOTVQQMJFEXJUIUIJTCBSCFDVF
-JRVJE1SPQBOF$ZMJOEFS3FRVJSFNFOUT
r$IFDLUPCFTVSFUIBUDZMJOEFSTIBWFB%05DFSUJGJDBUJPO, and that the date
tested  is within five years. Your LP gas supplier can do this for you.
r"MM-1UBOLTVQQMZTZTUFNTNVTUJODMVEFBDPMMBSUPQSPUFDUUIFDZMJOEFSWBMWF
r5IF-1DZMJOEFSNVTUCFBMCTJ[FBQQSPYJNBUFMZJODIFTIJHIBOEJODIFT
in diameter.
r5IFDZMJOEFSTIPVMECFDPOTUSVDUFEBOENBSLFEJOBDDPSEBODFXJUIUIF4QFDJGJDBUJPOT
for LP - Gas Cylinders of the U.S. Department of Transportation (D.O.T.) or the
National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes or
Transportation of Dangerous Goods; and Commission, as applicable.
$BOBEJBO-JRVJE1SPQBOF$ZMJOEFS3FRVJSFNFOUT
Note: Your retailer can help you match a replacement tank to your barbecue.
r5IF-1DZMJOEFSNVTUCFDPOTUSVDUFEBOENBSLFEJOBDDPSEBODFXJUIUIF
specifications for LP gas cylinders, T.C.
X