26 86317500 CHARIOT SCRUBBER
Maintenance
Service Schedule
Traction drive, wheels and batteries should be serviced based on traction drive hour meter (Deluxe). The scrub
brush hour meter should be used for all other service schedule items.
MAINTENANCE
BEFORE EACH
WORK PERIOD
AFTER EACH
WORK PERIOD
50
HRS
100
HRS
200
HRS
Check water level of batteries after charging; add
distilled water if necessary. (Wet cell only)
*
Check that dome and cover seal tightly. *
Visually check for damaged or worn tires. *
Check brushes or pads for proper installation. *
Check vacuum hose connections. *
Check that squeegee is securely attached and properly
adjusted.
*
Check for securely attached drain hoses, plug and cap. *
Check pedal, brake and steering for proper operation. *
Clean out recovery tank and dome basket. *
Clean and inspect float shutoff. *
Clean out solution tank and filter, check flow. *
Clean and inspect solution filter strainer. *
Run vacuum motors to dry. *
Clean brushes or pads and check wear. *
Clean squeegee blades and check wear. *
Clean outside of tanks, check for damage. *
Store with dome off tank or propped open. *
Charge batteries if needed. *
Clean off top of batteries. *
Check battery cells with hydrometer. (Wet cell only) *
Inspect scrub deck skirts and Aqua-Mizers. *
Clean solution strainer inside tank. *
Check battery connections are tight. *
Clean battery cases and battery compartment. *
Check parking brake. *
Clean cables and pulleys for squeegee lift. *
Clean pivot points on squeegee and scrub deck. *
Check all motors for carbon brush wear. *
Check motor commutators. *
Check steering chain tensioner. *
To Next Page
Loading...
Need help?
General