6-S1
M108S, WSM
FRONT AXLE
1. TROUBLESHOOTING
W1014322
Symptom Probable Cause Solution
Reference
Page
Front Wheels
Wander to Right or
Left
Tire pressure uneven Adjust G-69
Improper toe-in adjustment (improper alignment) Adjust 6-S4
Clearance between front axle case boss and
front axle bracket (front, rear) bushing excessive
Replace 6-S19
Poor tightening torque of front axle adjusting
screw
Adjust 6-S5
Tie-rod end loose Tighten 6-S10
Air sucked in power steering circuit Bleed –
Poor tightening torque of king pin pivot adjusting
screw
Adjust 6-S5
Front Wheels Can
Not Be Driven
Propeller shaft broken Replace 6-S7
Front wheel drive clutch in transmission broken Replace 3-S26
Front differential gear broken Replace 6-S15, 17
Shift fork broken Replace –
Coupling displaced Reassemble 6-S7
Noise Gear backlash excessive Adjust or replace 6-S17,
20 to 22
Oil insufficient Replenish 6-S7
Bearings damaged or broken Replace –
Gears damaged or broken Replace –
To Next Page
