Yamaha F40D - Page 110

To Previous Page

YAMAHA MOTOR CO., LTD.

Printed on recycled paper

Printed in Japan

April 2011–0.9  1 !

6C1-9-79-1E0.book 1 ページ２０１１年３月１７日　木曜日　午後２時５４分

Main Page

Table of Contents4
Safety Information7
Outboard Motor Safety7
Propeller7
Rotating Parts7
Hot Parts7
Electric Shock7
Power Trim and Tilt7
Engine Shut-Off Cord (Lanyard)7
Gasoline7
Gasoline Exposure and Spills8
Carbon Monoxide8
Modifications8
Boating Safety8
Alcohol and Drugs8
Personal Flotation Devices8
People in the Water8
Passengers8
Overloading8
Avoid Collisions9
Weather9
Passenger Training9
Boating Safety Publications9
Laws and Regulations9
General Information10
Identification Numbers Record10
Outboard Motor Serial Number10
Key Number10
EC Declaration of Conformity (Doc)10
CE Marking10
Read Manuals and Labels12
Warning Labels12
Specifications and Requirements16
Specifications16
Installation Requirements19
Boat Horsepower Rating19
Mounting Motor19
Yamaha Security System19
Remote Control Requirements19
Battery Requirements20
Battery Specifications20
Mounting Battery20
Multiple Batteries20
Propeller Selection20
Start-In-Gear Protection21
Engine Oil Requirements21
Fuel Requirements21
Gasoline21
Anti-Fouling Paint22
Motor Disposal Requirements22
Emergency Equipment22
Components23
Components Diagram23
Fuel Tank25
Fuel Joint25
Fuel Gauge26
Fuel Tank Cap26
Air Vent Screw26
Remote Control Transmitter26
Receiver26
Yamaha Security System Lock and Unlock Mode27
Remote Control Box27
Remote Control Lever27
Neutral Interlock Trigger28
Neutral Throttle Lever28
Tiller Handle28
Gear Shift Lever28
Throttle Grip29
Throttle Indicator29
Throttle Friction Adjuster29
Engine Shut-Off Cord (Lanyard) and Clip30
Engine Stop Button30
Main Switch31
Steering Friction Adjuster31
Power Trim and Tilt Switch on Remote Control or Tiller Handle32
Power Trim and Tilt Switch on Bottom Cowling32
Variable Trolling RPM Switches33
Trim Tab with Anode33
Trim Rod (Tilt Pin)34
Tilt Lock Mechanism34
Tilt Support Lever for Power Trim and Tilt or Hydro Tilt Model34
Cowling Lock Lever(S) (Turn Type)35
Flushing Device35
Fuel Filter/Water Separator35
Alert Indicator36
Instruments and Indicators37
Indicators37
Low Oil Pressure-Alert Indicator37
Overheat-Alert Indicator37
Digital Tachometer37
Tachometer38
Trim Meter38
Hour Meter38
Low Oil Pressure-Alert Indicator38
Overheat-Alert Indicator39
Digital Speedometer39
Speedometer39
Fuel Gauge39
Trip Meter / Clock / Voltmeter40
Fuel Level-Alert Indicator41
Low Battery Voltage-Alert Indicator41
Analog Tachometer41
Low Oil Pressure-Alert Indicator41
Overheat-Alert Indicator42
Analog Trim Meter42
6Y8 Multifunction Meters42
6Y8 Multifunction Tachometers42
Start-Up Checks43
Yamaha Security System Information44
Adjusting Trolling Speed44
Low Oil Pressure-Alert45
Overheat Alert45
Water Separator Alert46
Engine Trouble Alert46
Low Battery Voltage-Alert47
6Y8 Multifunction Speed & Fuel Meters47
6Y8 Multifunction Speedometers48
6Y8 Multifunction Fuel Management Meters49
Engine Control System50
Alert System50
Overheat Alert50
Low Oil Pressure Alert51
Installation52
Mounting the Outboard Motor52
Operation54
First-Time Operation54
Fill Engine Oil54
Breaking in Engine54
Getting to Know Your Boat54
Checks before Starting Engine54
Fuel Level54
Remove the Top Cowling55
Fuel System55
Controls55
Engine Shut-Off Cord (Lanyard)56
Engine Oil56
Engine57
Flushing Device57
Install Top Cowling57
Power Trim and Tilt System58
Battery58
Filling Fuel59
Operating Engine60
Sending Fuel (Portable Tank)60
Starting Engine61
Checks after Starting Engine64
Cooling Water64
Warming up Engine64
Manual Start and Electric Start Models64
Checks after Engine Warm up65
Shifting65
Stop Switches65
Stopping Boat66
Trolling67
Adjusting Trolling Speed67
Stopping Engine67
Procedure67
Trimming Outboard Motor68
Adjusting Trim Angle (Power Trim and Tilt)69
Adjusting Trim Angle for Hydro Tilt Models70
Adjusting Boat Trim70
Tilting up and down71
Procedure for Tilting up (Hydro Tilt Models)71
Procedure for Tilting up (Power Trim and Tilt Models)72
Procedure for Tilting down (Hydro Tilt Models)73
Procedure for Tilting down (Power Trim and Tilt Models)74
Shallow Water75
Hydro Tilt Models75
Power Trim and Tilt Models76
Cruising in Other Conditions77
Maintenance78
Transporting and Storing Outboard Motor78
Storing Outboard Motor78
Procedure79
Lubrication80
Flushing Power Unit81
Cleaning the Outboard Motor82
Checking Painted Surface of Outboard Motor82
Periodic Maintenance82
Replacement Parts83
Severe Operating Conditions83
Maintenance Chart 184
Maintenance Chart 286
Greasing87
Cleaning and Adjusting Spark Plug88
Inspecting Idle Speed89
Changing Engine Oil90
Inspecting Wiring and Connectors91
Checking Propeller92
Removing Propeller92
Installing Propeller93
Changing Gear Oil94
Cleaning Fuel Tank95
Inspecting and Replacing Anode(S)95
Checking Battery (for Electric Start Models)96
Connecting the Battery97
Disconnecting the Battery97
Storing the Battery97
Trouble Recovery99
Troubleshooting99
Temporary Action in Emergency102
Impact Damage102
Replacing Fuse103
Power Trim and Tilt will Not Operate103
Water Separator-Alert Indicator Blinks While Cruising104
Starter will Not Operate107
Emergency Starting Engine107
Treatment of Submerged Motor108

Related product manuals

Yamaha F40FEHT F40FEHD

226 pages

Yamaha F40D - Page 110

Table of Contents

Related product manuals