Ametek 5000

iv 5000 Multi Point Moisture Analyzer
Software Configuration
Level 2 Configure Menu ............................................................................ 4-1
Constants .............................................................................................4-1
Display (Display Flags) .....................................................................4-2
Analog (Analog Flags) .......................................................................4-2
Passwords ............................................................................................4-2
Timing .................................................................................................4-3
Moist_Gen ........................................................................................... 4-4
Serial .....................................................................................................4-4
Flags1 (Configuration Flags) ............................................................4-4
Noise ....................................................................................................4-4
Level 3 Configure Menu ............................................................................ 4-5
PolyCoef (Polynomial Coefficients) ................................................4-6
Labels ...................................................................................................4-6
Constants .............................................................................................4-6
Flags2 (Configuration Flags) ............................................................4-7
Level 2 Config Menu (Go To) ...........................................................4-7
Timers (Measurement Cycle Timers) ..............................................4-7
Default Memory (Reset to Factory Default) .................................. 4-7
Coef_D (Polynomial Coefficient D) ................................................4-8
Configuring for Multi-Point Operation ................................................... 4-9
Serial Communication
Hardware Requirements ...........................................................................5-1
Wiring Configuration and Baud Rate ......................................................5-1
Serial Communication Wiring ..................................................................5-1
Read and Write Protocol ............................................................................ 5-3
Table III: Read Only System Values ........................................................5-3
Table III: Read and Write System Values ................................................ 5-4
Troubleshooting & Maintenance
System Alarms .............................................................................................6-1
System Test Menu .......................................................................................6-2
Scheduled Maintenance ............................................................................6-4
Troubleshooting...........................................................................................6-5
Field Unit Electronics .................................................................................6-9
Field Unit ......................................................................................................6-13
Service and Parts
Service ...........................................................................................................7-1
Field Unit Parts List ....................................................................................7-2
Controller Parts List ....................................................................................7-4
Controller .....................................................................................................7-5
CPU/Display PC Board ..............................................................................7-6
Relay PC Board ............................................................................................7-7
5000 INPUT - OUTPUT ..............................................................................7-8