Convotherm OEB Series User Manual

Service Handbook OEB/OES/OGB/OGS
AS/11-2011 4_07e_Installation Checklist_c
yes!
Maintenance  User Manual Chapter ‚Daily maintenance and care’
 Have you recommended to the user a yearly maintenence by an authorized Service partner? To
ensure, that the CONVOTHERM combination oven steamer is technically problem free (
User
Manual Chapter
‚Safety advice’).

 Has the user been advised of required regular training and safety instruction
of the personnel (User Manual Chapter ‚Safety advice’)?

 Has the user been advised to regularly (at least once a year) test the screws
and disappearing door hinges for tightness?

 Have you advised the user that the guiding stirrup for the disappearing door must be wiped
monthly with a grease cloth? This will guarantee a longer life span.

 Has the user also been advised that the hand shower must only be used for cleaning the inside
of the oven (not the outer casing)? Do not spray on the air inlets and outlets or the gas exhaust
openings of the combination oven steamer.

 Has the user been advised that cleaning and maintenance work can only be performed
on a cold oven? Do not spray with hand shower into a hot oven! Allow
CONVOTHERM to cool
down to at least 60°C.

 Has the user been advised that when cleaning the CONVOTHERM, no high pressure cleaner
and no water jet is allowed to be used?

 Has the user been advised that no acid treatment or acidic steam is allowed to be used on the
combination oven steamer, as the stainless steel can corrode?

 Has the user been advised that the combination oven steamer can only be decalcified by a
trained Service person? Observe as well the following:
 Never operate combination oven steamer with decacifying solution. Decalcification can only be
performed in a cold oven.
 Thoroughly remove decalcifying residue immediately with a lot of water.

 Has the user been advised that the glass pane in the inner door must be replaced
if there is surface damage (notches, cracks or other faults), as these may cause
breakage?

 Has the user been advised that high cooking temperatures may cause the inside door to
slightly distort shortly when it is opened?

Checklist Page 4 from 4
In the case of damages that can be attributed to improper set up, installation, use, cleaning
,maintenance, repair and decalcification, all warranties are invalid.
The unit was installed according to the information
in this Installation Manual:
All points on the checklist have been checked off by
the instal
ler. The installation of the unit is not
allowed Date Signature Installer
to be changed without consulting an authorized expert:
The user has been informed of all important
functions and safety relevant points. Date: Signature Customer:
Page 4 / 4

Convotherm OEB Series Specifications

General

Brand	Convotherm
Model	OEB Series
Category	Commercial Food Equipment
Language	English