Convotherm OEB Series User Manual

Service Handbook OEB/OES/OGB/OGS
Operation Instructions:
1. Before starting, remove food rests or cooking residue from the oven to avoid
blockage of the oven drain.
2. Check that the containers for CONVOTHERM oven cleaner and spray solution
are full. The containers must be full. The suction hose must be in the liquid.
3. Press
key → Selection possibilities are indicated in display. With the
selector knob select ‚CONVOClean system’
and confirm by pressing the
key.
4. To select the cleaning levels
1 light soiling
2 medium soiling
3 strong soiling
4 strong soiling-shining+
Press
and select with the selector knob depending on the build up on the
oven. Choose a higher level for heavier build up.
5. Press
key →On the display, two safety questions will appear, one after
the other. Answer the questions using the selector knob and confirm by
pressing
key.
6. The CONVOTHERM starts the CONVOClean system automatically.
7. After Automatic Cleaning has ended spray weekly spray weekly into the
steam measuring opening (finger thick opening in the oven in the area
behind the door lock) approx. 20 ml CONVOClean forte and rinse out
again with the hand shower.
8. Leave the oven door ajar after use or cleaning (airing position).
Advice:
 Grease build up on the bypass pipes can lead to problems in the programmes
with steaming, i.e. heavy wash off in Superheated steaming or puddles on the
plates in regeneration.
 Outside of the oven, areas such as the parts of the door and the oven gasket
must be manually cleaned.
 For heavy build up in the oven, certain places may require a manual cleaning
afterwards.
 Hot air sterilization and shining + can be adjusted in the Service level. See
"Chapter 2.3.5 Automatic Cleaning".
 After a manual cleaning, a lower cleaning level can be used and thereby save
water and cleaner.
 Depending on the build up level of the oven, the hanging rack and shelves can
remain in the oven during the automatic cleaning CONVOClean system.
 Depending on the water quality (high silicate), after a time, dark discolouration
can occur in the oven. This discolouration can be removed by treating with
CONVOCare-concentrate. Spray CONVOCare-concentrate into a cold oven.
Allow to work for 10 minutes and wipe out the oven with a soft cloth or sponge.
AS/11-2011 4_03e_Cleaning the Unit_c
Page 4 / 7

Convotherm OEB Series Specifications

General

Brand	Convotherm
Model	OEB Series
Category	Commercial Food Equipment
Language	English