Home
Edwards
Water Pump
nEXT300
Edwards nEXT300 User Manual
5
of 1
of 1 rating
108 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Figure 17
Conceptual diagr
am f
or
mul-drop
connecon
using RS232 in
terf
ace
1.
RS232 interf
ace on con
trol equipment
2.
Buer
3.
pump
4.
OR gate
1.
RS232 interf
ace on con
trol equipment
2.
Buer
3.
pump
4.
OR gate
04/2022 - ©Edw
ards Limit
ed
Pag
e 51
B80000880_G
B80000880_G -
Inst
allaon
50
52
Table of Contents
Table of Contents
3
Safety and Compliance
8
Definition of Warnings and Cautions
8
Safety Symbols
9
Trained Personnel
9
Introduction
11
Overview
11
Pump Model Description
12
Pump Controller
12
Figure 1 Pump Model Description
12
Operational Features
13
Power Limit Setting
13
Standby Speed
13
Timer
14
Analogue Output
14
Automatic Vent Options
15
Normal Speed Setting
15
Logic Interface
15
Parallel Control and Monitoring
16
Serial Control and Monitoring
16
Serial Control with Parallel Monitoring
16
Parallel Control with Serial Monitoring or Serial Configuration
17
Controller Configuration (Serial Configuration)
17
Technical Data
18
General Technical Data
18
Figure 2 Next240 Performance Curve
22
Figure 3 Next300 Performance Curve
23
Figure 4 Next400 Performance Curve
23
Figure 5 Next 240 Dimensions (MM)
24
Figure 6 Next 300 Dimensions (MM)
25
Figure 7 Next 400 Dimensions (MM)
26
Operation and Storage Environment
27
Vent Gas Specification and Vent Control Data
27
Purge Gas Specification
28
Cooling Water
28
Figure 8: Max Allowed Rate of Pressure Rise During Venting: Pressure against Time
28
Electrical Data
29
Pumping Media
29
Materials Exposed to Gases Pumped
31
Logic Interface Connector
31
Controller Connector Socket
34
Figure 9 Interface Circuits for Next Turbo Pump Controllers
34
Indicator Led's
35
Figure 10 Controller Connector Showing Pin Numbers
35
Installation
37
Unpack and Inspect
37
Typical Installation
38
Connect to the Vacuum System
38
Inlet Screen (Installed on CF Only)
39
Figure 11 Typical Pumping System with a Next Pump
39
Mechanical Fixing
40
Inlet Connection and Orientation
41
Figure 12 Installation Orientation
41
Base Mounting
42
Backing Port Connection
42
Interstage Connection (Variants Only)
43
Purge Gas Connection
43
Recommended Purge Gas Flow
43
Connect the Purge Gas
43
Electrical Installation
43
Ground the Connections
44
Connect the Logic Interface to the TIC
44
Connect the Logic Interface to the Customer Control Equipment
44
Connect the Electrical Supply
45
Connect the Parallel Control and Monitoring
46
Figure 13 Logic Interface Connections - Parallel Control
46
Connection for Serial Control and Monitoring
47
Connect the Serial Interface to the Customer Control Equipment
47
Figure 14 Controller Status Information
48
Serial Enable
49
Figure 15 Logic Interface Connections - RS232 Serial Control
49
Figure 16 Logic Interface Connections - RS485 Serial Control
49
Serial Protocol
50
Figure 17 Conceptual Diagram for Multi-Drop Connection Using RS232 Interface
51
Message Structure
52
Command Set
52
Figure 18 RS485 Multi-Drop Connection
52
Multi-Drop Operation
55
Connection for Mixed Parallel and Serial Operation
56
Vent Options, Vent Valve Connection and Control
57
Figure 19 Logic Interface Connection - Mixed Parallel and Serial Operation
57
Manual Vent Valve
58
TAV5 or TAV6 Solenoid Vent Valve
58
Vent Valve Control
59
Alternative Valve Connected to the Vacuum System
60
Cooling
60
Introduction
60
Forced Air Cooling
61
Water Cooling
61
Figure 20 Maximum Relative Humidity to Avoid Condensation with Water Cooling
62
Configuration
63
Configure the Pump Using Serial Commands
63
Power Limit Setting
63
Power Supply to the Fan from the Controller
64
Controlled Venting Options
64
Standby Speed Setting
65
Normal Speed Setting
65
Timer Setting and Options
66
Analogue Signal Options
67
Factory Settings
67
Assigning a Multi-Drop Address
67
Configuring the Next Pump Using a TIC
68
Operation
70
Before Starting the Pump
70
Close the Vent Valve
70
Pre-Start Sequence
70
Operation with Parallel Control and Monitoring
71
Start the Pump
71
Running at Standby Speed
71
Stop the Pump
71
Parallel Monitoring
71
Operation with Serial Control and Monitoring
71
Delayed Start
71
Start the Pump
72
Standby Speed
72
Stop the Pump
72
Temperature Readings
73
Link Parameter Readings
73
Measured Motor Speed
73
Mixed Parallel and Serial Operation
74
Operation with a TIC
75
Decelerating and Venting
75
Figure 21 Serial and Parallel Control Flowchart
75
Operation at Extreme Conditions
76
Operation with High Inlet Pressure
76
Operation at High Temperatures
76
Protection against Over-Speed
76
Electrical Supply Failure
77
Bakeout
77
Maintenance
80
Introduction
80
Bearing and Oil Cartridge Maintenance
80
Rotor Life
80
Clean the External Surfaces of the Pump
81
Fault Finding
82
Flashing Service Codes
85
Decoding Service Status Words
86
Controller Run Time
87
Pump Run Time
87
Pump Cycles
87
Bearing Run Time
88
Oil Cartridge Run Time
88
Flashing Error Codes
88
Decoding System Status Words
89
Useful Service Information
91
Storage
93
Disposal
94
Service
95
Return the Equipment or Components for Service
95
Bearing and Oil Cartridge On-Site Maintenance
96
Spares
97
ISX Inlet Screen
97
Inlet Strainer
97
Inlet-Flange Seals and Integrated Inlet Screens
97
NW16 and NW25 Ports
98
Accessories
99
Installation
99
Figure 22 Next Exploded Accessories View
99
ACX Air Cooler
100
Figure 23 Next Exploded Accessories View
100
WCX Water Cooler
101
BX Bakeout Band
101
TAV Vent Valve and Vent Port Adaptor
101
VRX Vent Restrictor
101
Vent Port Adaptor
102
PRX Purge Restrictor
102
C-Clamp Adaptor Kit
102
Interface Cable
103
TIC PC Program
103
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Edwards nEXT300 and is the answer not in the manual?
Ask a question
Edwards nEXT300 Specifications
General
Brand
Edwards
Model
nEXT300
Category
Water Pump
Language
English
Related product manuals
Edwards nEXT
20 pages
Edwards nEXT85
106 pages
Edwards nEXT400
108 pages
Edwards nEXT730D
120 pages
Edwards nEXT 240D
94 pages
Edwards nEXT 730D
32 pages
Edwards nEXT200200
100 pages
Edwards nES Series
56 pages
Edwards nXDS6i
58 pages
Edwards nXDS Series
52 pages
Edwards nXLi Series
40 pages
Edwards nXDS10i nXDS15i
24 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
