ep EPT20-ET2 - Battery Charging; Precautions; Charging the Battery with Internal Charger

REV. 09/2022 REV. 09/2022
C2
C3
1.2 Battery charging
•The truck must be parked within a shady and ventilated room;
•Avoid the existence of any metal object in the surface of the storage battery;
•All the cable and plug connection parts should be inspected in terms of obvious damages before
charging;
•The charger to be connected or disconnected must be under the state of not connecting to the
circuit;
•The safety provisions related to the storage battery and the manufacturer of charging station must
be strictly abode by.
•Charging in non-charging area is prohibited;
•No modication of vehicles;
•Do not use irregular charging sockets;
•The net height of the charging area shall be higher than 5m, and the safe distance from other
areas shall be greater than 5m.
Charging environment:
1.2.2 Charging the battery with internal charger
Charge lithium battery through a built-in charger
•Inspect whether relevant charging requirements are satised according to “1.1.1 precautions”;
•Park the truck securely as described chapter B Section1.2.6;
•Open the upper cover if necessary;
•Connect the power plug and have it inserted into a proper power supply.
1.2.1 Precautions
Lithium battery must be charged above 0°C, as excessively low charging temperature is likely to
result in the short circuit of battery cell.
power plug
power plug
Charging indicator
Charging indicator
LED Fault Indicator
• No smoke and re!
• Avoid the existence of
open re, ery metal wire
or sparks around the
storage battery, otherwise
explosion or re disaster
may occur!
•Don’t trample on the storage
battery to prevent it from
erce shaking or shacking!
Do not place the battery on
top of conductive objects.
• Dangerous voltage!
• Avoid hot plugging!
• Notice: the metal part of
the storage battery cell is
electried, so don’t place any
external object or tool on the
battery cell!
Avoid the battery becoming
corroded by water or corrosive
liquid.
Keep the battery away from all
re sources, heat sources and
ammable or explosive
materials.
In the event of accidental contact with electrolyte, the eyes shall be immediately ooded with
large quantities of water for an extended period of time. In all cases immediate medical
attention shall be obtaine
In the event of accidental skin contact with electrolyte, the aected parts shall be washed with
large quantities of water or with adequate neutralizing solutions. If irritation of skin persists
medical attention shall be obtaine.
Accidental contact, "rst aid"
Acid and alkaline electrolytes create burns in eyes and on the skin.
A source of clean water, from tap or a dedicated sterile reservoir, shall be provided in the
vicinity of the battery under charging or maintenance for removing electrolyte splashed onto
body parts.
WARNING
EPT20-ET2 EPT20-ET2L