B
MAINTENANCE
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
49
Owner’s Manual
BRAKES
Always inspect the pedal travel before you operate a vehicle to confirm brake function.
Make sure you do all brake tests in a safe location with regard to the safety of all personnel.
A subtle loss of performance can occur over time; therefore, it is important to establish the standard with a new
vehicle.
The Periodic Brake Performance Test should be performed regularly as an evaluation of braking system performance. It
is useful as a method of identifying subtle loss of performance over time.
LUBRICATION
Do not use more than three pumps of grease in any grease fitting at any one time. Excess grease may cause
grease seals to fail or grease migration into areas that could damage components.
Putting more than three pumps of grease in a grease fitting could damage grease seals and cause premature bearing
failure.
CAPACITIES AND REPLACEMENT PARTS
CAPACITIES
Engine Oil 1.25 L (1.3 qt.)
Fuel Tank (early produc-
tion)
5.1 gal (19.3 liters) 87 Octane minimum
Fuel Tank (late produc-
tion)
5.2 gal (19.8 liters) 87 Octane minimum
Rear Axle Lubricant Oil 1.5 L (51 oz.)
REPLACEMENT PARTS
Oil Filter E-Z-GO P/N 607454
Air Filter E-Z-GO P/N 28463G01
Spark Plug NGK BPR2ES (E-Z-GO P/N 607462)
Starter/Gen. Belt E-Z-GO P/N 16548G1
Clutch Belt E-Z-GO P/N 606136
Fuse ATC 10A (E-Z-GO P/N 35212G07)
Headlight Bulb #894 (E-Z-GO P/N 74004G01)
Turn Signal Bulb #912-NA (E-Z-GO P/N 74005G01)
Taillight Bulb 2057 (E-Z-GO P/N 604311)
To Next Page
Loading...
Need help?
General
