GPX DZ3 - Maintenance and Adjustment; Importance of Maintenance; Inspection Routine; Engine Oil Inspection and Change

21
Maintenance and adjustment
Details
Checking Point
Engine oil
The engine oil level is at the correct level
Fuel
Fuel is sufficientno leakage
Brake
Frontrear brakes are effective
Tire
There is a tire inflation cap, sufficient pressure, and no damage
Handlebar
Is there any abnormal vibration or is it difficult to rotate?
Coolant
The coolant level is correct
Electrical equipment
Work efficiently
Bolts, nuts, screws
Normally tightenednot loose
Importance of Maintenance
The maintenance and adjustments mentioned in this chapter must be carried out according to the Routine Inspectionand
Periodic Maintenance Scheduleto keep
the motorcycle in good condition and reduce air pollutionMaintenance is the responsibility of the ownerBe sure to inspect
your vehicle beforeevery ride and perform regular checksThe first maintenance is very important and must be done
 Warning
Always follow the inspection, maintenance and interval instructions specified in this vehicleowner's manual
GPX cannot warn you of every possible incident that may occur while using the vehicleOnly you can decide whether you
should take the prescribed action or notIf you do not understand or have any doubts, please contact your authorized GPX
dealer for adjustment, maintenance and repair
Audit Routine
Checking the Engine Oil LevelChanging the Engine Oil Level
Checking
Start the engine to warm up for about  minutes
Turn off the engine and leave it for about  minutes to allow the engine oil to drain into the oil pan
Stand the motorcycle upright and check the engine oil level on the dipstick by removing the dipstick Aand wiping it clean
Insert the dipstick until it clicks into placeTurn the dipstick all the way inThe oil level should be between MAX and MIN
Fill the engine oil to the upper line when the engine oil level is low
Check the engine oil level every ,km
(A)