AJX-44 & AJX-54 Series Technical Manual 7610-003-60-98
Issued: 01-19-2009 Revised: 01-30-2009
SECTION 5: PARTS SECTION
AJX-44 & AJX-54 CONTROL BOX ASSEMBLY (CONTINUED)
40
ITEM QTY DESCRIPTION Mfg. No.
1 1 Electrical Box Weldment 05700-041-88-43
2 1 Terminal Block, 3 Pole 05940-011-48-27
3 1 Rinse Thermometer, 96” Lead 06685-111-68-49
1 Rinse Decal, 180F 09905-002-97-62
4 6 Star Washer, External Tooth, 10-24 05311-273-02-00
5 6 Screw, 10-32 x 3/4” Long Phillips Trusshead 05305-011-62-17
6 1 Decal, Gauge 09905-021-72-29
7 1 Wash, Thermometer, 48” Lead 06685-111-68-48
1 Wash Decal, 160F 09905-003-00-69
8 1 Wire Lug, 2 AWG to 14 AWG 05940-200-76-00
9 1 Decal, Ground 09905-011-86-86
10 2 Screw, 10-32 x 1/2” Long Phillips Trusshead 05305-011-39-36
11 1 Decal, L1-L2-L3 09905-101-12-66
12 1 Light, Amber 05945-111-44-44
13 1 Light, Red 05945-111-44-45
14 1 Din Rail 05700-021-72-75
15 1 Circuit Breaker (208-230 Volt, 60 Hz Models Only) 05925-011-68-34
16 1 Switch, ON/FILL - OFF/DRAIN 05930-301-46-00
17 2 Motor Contactor 05945-111-68-38
18 1 Heater Contactor 05700-002-24-70
19 1 Overload See Page 48
20 1 Overload See Page 48
21 1 Control Relay 05945-111-35-19
21 2 Control Relay 05945-111-72-51
22 10 Screw, 6-32 x 3/8” Long Round Phillipshead 05305-002-25-91
23 1 Fuse (460 Volt, (all 60 Hz) Models Only) 05920-011-72-88
24 1 Fuse Holder for (23) Above 05920-011-72-89
25 1 Transformer 208-220-230-460 Volt Models 05950-011-68-35
26 4 Locknut, 10-24 with Nylon Insert 05310-373-01-00
27 1 Terminal Board 05940-002-78-97
28 1 Terminal Board 05940-021-89-41
MISCELLANEOUS PARTS NOT SHOWN:
Grommet, 1/2” OD x 3/8” ID 05325-011-46-73
Bushing, Heyco SB100 05975-210-09-00
Plug, Heyco 2700 G-875 05975-011-47-81
Control Box Cover 05700-031-66-88
Control Box Cover Hinge Weldment 05700-021-68-57
Cotter Pin 05315-011-68-56
MANUAL/DELIME Switch (located on rear of control box) 05930-301-22-18
MANUAL/DELIME Switch Decal (located on rear of control box) 09905-011-74-61
Copper Conductors Only Decal 09905-011-47-35
Decal, Operation 09905-002-82-33
Decal, High Limit Light Warning 09905-002-49-48
Control Box Leg 05700-011-71-47
Component Mounting Plate (located inside the control box) 05700-031-67-03
Conduit Bracket 05700-021-70-88
To Next Page
