Kioti CK20 - OPERATING THE ENGINE

136 pages

Save Page as PDF

To Next Page

To Previous Page

STARTING THE ENGINE

STOPPING THE ENGINE

WARMING UP

JUMP STARTING

6OPERATING THE ENGINE

Main Page

Foreword1
Abbreviation List2
Universal Symbols3
Table of Contents5
Safety Precautions7
- Before Operating the Tractor8
- Driving the Tractor14
- Parking the Tractor15
- Operating the P.T.O.16
- Using 3-Point Hitch16
- Servicing the Tractor17
- Tractor Safety Labels20
- Servicing of Tractor25
- Kioti Tractor26
Servicing26
Specifications27
- Implement Limitations30
- Instrument Panel and Controls33
- Instrument Panel, Switches and Hand Controls34
- Foot and Hand Controls35
Instrument Panel and Controls35
Pre-Operation Check37
Daily Check38
Operating the Engine39
- Starting the Engine40
- Check Easy Checker Lamps42
- Stopping the Engine44
- Warm-Up and Transmission Oil in the Low Temperature Range44
- Warming up44
- Jump Starting45
Operating the Tractor47
- Changing Lubricating Oil for New Tractors48
- Operating New Tractor48
- Operating Rops49
- To Fold the Rops49
- To Raise the Rops to Upright Position50
- Adjusting the Operator’s Position51
- Seat Belt51
- Starting51
- Travel Adjustment51
- Hazard Light Switch52
- Head Light Switch52
- Selecting Light Switch Positions52
- Turn Signal Light Switch52
- Checking the Brake Pedal53
- Depress the Clutch Pedal54
- Raise the Implement54
- Іelecting the Travel Speed55
- Main Gear Shift Lever56
- Range Gear Shift Lever (HI-LO)56
- CK20H View57
- Accelerate the Engine58
- Foot Throttle58
- Front Wheel Drive Lever58
- Hand Throttle Lever58
- Forward Pedal59
- Parking Brake Lever59
- Reverse Pedal59
- Speed Control Pedal59
- Live P.T.O. (CK20H)60
- To Disengage Speed Set Device60
- To Engage Speed Set Device60
- Horn (Only EU)61
- Stopping61
- Check During Driving62
- Immediately Stop the Engine if62
- Easy Checker63
- Electrical Charge Indicator63
- Engine Oil Pressure Indicator63
- Coolant Temperature Gauge64
- Fuel Gauge64
- Hourmeter/Tachometer64
- Handbrake (Only EU-CK20)65
- Parking65
- Seat (Only EU)66
- Differential Lock67
- Operating Techniques67
- Operating the Tractor on a Road67
- Directions for Use of Power Steering68
- Operating on a Slopes and Rough Terrain68
- P.T.O. Gear Shift Lever69
- P.T.O. Operation69
- P.T.O. Shaft Cover and Shaft Cap69
- MID-P.T.O. Lever70
- MID-P.T.O. Shaft Cover70
- Rear and MID -P.T.O. Speed70
Three-Point Hitch & Drawbar71
- 3-Point Hitch73
- Drawbar73
- Lifting Rod (Right)73
- Selecting the Top Link Mounting Holes73
- Adjusting Drawbar Length74
- Check Chains74
Hydraulic Unit75
- 3-Point Hitch Control System76
- Hydraulic Control76
- Hydraulic Block Type Outlet77
- Implement Lowering Limit77
- Lower Limit77
- When Implement Is Attached77
- Auxiliary Hydraulics79
- Joystick Valve79
- Remove Valve Type79
- Remote Control Valve Coupler Connecting and Disconnecting80
- Remote Control Valve Lever81
- Hydraulic Control Unit Use Reference Chart82
- Tires, Wheels and Ballast83
- Inflation Pressure84
- Tires84
- Front Wheels85
- Rear Wheels85
Tires, Wheels and Ballast85
- Tread85
- Ballast (Optional)86
- Front End Weights86
- Rear Wheel Weights86
- Traveling Speed87
Maintenance89
- Service Intervals90
- Lubricants92
Periodic Service93
- Engine Cover94
- How to Open the Hood94
- Checking Engine Oil Level95
- Checking and Refueling96
- Checking Transmission Fluid Level96
- Checking Brake and Clutch Pedals98
- Checking Coolant Level98
- Checking Gauges, Meter and Easy Checker99
- Checking Head Light, Hazard Light Etc.99
- Checking Seat Belt and Rops99
- Cleaning Grill, Radiator Screen and Oil Cooler Screen99
- Every 50 Hours100
- Lubricating Grease Fittings100
- Checking Wheel Bolt Torque101
- Changing Engine Oil102
- Cleaning Air Cleaner Primary Element102
- Every 100 Hours102
- Evacuator Valve103
- Checking Fuel Line104
- Cleaning Fuel Filter104
- Adjusting Brake Pedal105
- Adjusting Clutch Pedal105
- Adjusting Handbrake (Only EU-CK20)106
- Battery Charging107
- Direction for Storage108
- Adjusting Fan Belt Tension109
- Every 200 Hours110
- Replacing Engine Oil Filter110
- Replacing Hydraulic Oil & Transmission Oil Filter (CK20H)110
- Checking HST Oil Line (CK20H) & Power Steering Line112
- Checking Radiator Hose and Clamp112
- Precaution at Overheating112
- Adjusting Procedure113
- Adjusting Toe-In113
- Changing Transmission Fluid114
- Every 400 Hours114
- Changing Front Axle Case Oil115
- Every 1 Year116
- Every 600 Hours116
- Every 800 Hours116
- Every 2 Year117
- Anti-Freeze118
- Replacing Fuel Hose118
- Replacing HST Oil Line118
- Replacing Power Steering Hose118
- Bleeding Fuel System119
- Bleeding Procedure Is as Follows119
- Service as Required119
- Replacing Fuse120
- Protected Circuit121
- Replacing Light Bulb121
Storage123
- Tractor Storage124
- Removing the Tractor from Storage125
Troubleshooting127
Engine Troubleshooting128
Options131
Index133

Kioti CK20 - OPERATING THE ENGINE

Table of Contents

Other manuals for Kioti CK20

Related product manuals