Kohler KDI 3404TCR-SCR User Manual

INFORMATION ABOUT FAILURES
7
53
EN
7 INFORMATION ABOUT FAILURES
7.1 Useful information about failures
•
This chapter contains information about the problems that may appear during engine operation
with its causes and trouble shooting Tab. 7.2 .
•
In some cases, you shall turn off the engine immediately to avoid further damage Tab. 7.1 .
7.1
THE ENGINE MUST BE IMMEDIATELY TURNED OFF WHEN
1
Warning RED light turn on
2
The oil pressure indicator light turns on while running
3
The engine rpms suddenly increase and decrease
4
A sudden and/or unusual noise is heard
5
Colour the exhaust fumes suddenly darkens
7.2
TROUBLES
POSSIBLE CAUSE
SOLUTION
PAR.
Warning YELLOW
light turn on
Engine ECU has detect
a malfunctions
Contact KOHLER authorised workshops
--
The engine does not
start
Sulphated battery
terminals corroded
Clean the battery terminals --
Battery voltage too low
Recharge the battery or replace it
--
Low fuel level
Refuel
4.4
Frozen fuel
Contact KOHLER authorised workshops
--
Clogged fuel filter
Replace with a new filter
6.3
Air suction in fuel
system
Contact KOHLER authorised workshops --
Clogged air filter Replace with a new filter
6.4
Clogged pipes
Contact KOHLER authorised workshops
--
Intake or exhaust
system clogged
Replace with a new fuse; if the problem
persists,
Contact KOHLER authorised workshops
--
Intake or exhaust
system clogged
Contact KOHLER authorised workshops --
Engine starts but
stops
Inefficient electrical
connections
Clean the electrical contacts; if the problem
persists,
Contact KOHLER authorised workshops
--
Sulphated battery
terminals
Clean the battery terminals
--
Clogged fuel filter
Replace with a new filter and clean the tank
--
Clogged fuel pipes
Contact KOHLER authorised workshops
--
Engine doesn't rev up
Safety protocol in
starting
Wait some seconds
--

Kohler KDI 3404TCR-SCR Specifications

General

Brand	Kohler
Model	KDI 3404TCR-SCR
Category	Engine
Language	English