Manitowoc Multiplex Ms-8 User Manual

1/12 15
Clean Blended Ice Machine (BIM-8)(continued)
©McDonald’s Corporation · Planned Maintenance Manual · October 2011 Page 4 of 5
Ble Blended Ice Machine Models MS-8-1H, MS-8-1LH, MS-8-EH, MS-8-ELH, MS-8-BH, MS-8-BLH, MS-8-CH, MS-8-CLH, MS000A03, MS000A04
Weekly BE 23 W1
31
With the blender pitchers at
the 3-compartment sink:
Place one KAY Beverage
Equipment Cleaner packet
into the first pitcher and fill
with hot water from the back
sink. Allow the product to
soak in the pitcher for 5
minutes. Use a no-scratch pad
to remove any film build-up.
Pour the solution into the
second pitcher and soak for 5
minutes. Once this is done,
discard solution and rinse and
sanitize both pitchers in the 3-
compartment sink. Allow to
air dry.
KAY Beverage Equipment
Cleaner
32
Sanitize ice chute
Use a spray bottle with
Sanitizer solution and a
sanitized towel to sanitize:
x Above and around the
ice chute
x Inside the ice chute
KAY 5 Sanitizer
33
Clean pitcher pad and drain
area.
x Use coffee pot of hot
water from the back
sink to rinse drain
area and drain.
x Spray the drain area
with Sanitizer
solution and wipe
with a clean sanitize
towel.
x Clean top and sides
of the pad.
KAY 5 Sanitizer
34
Re-install all components.
Blend pitchers, scale overflow
tray, ice hopper lid, syrup
rails, drip pan and splash
guard.
35
Clean with APSC the interior of
the blended ice machine with a
clean, sanitized towel
dampened with KAY 5
Sanitizer solution:
x Clean inside the
machine.
x Pull out the whipped
cream holder and clean
the holder and sides
inside the machine that
hold the holder
x Clean all door gaskets
KAY 5 Sanitizer
36
Clean with APSC the exterior
of the blended ice machine
with a clean, sanitized towel
dampened with KAY 5
Sanitizer solution:
x Clean lid holders, cup
holder tubes, cabinet,
front of door, top of
work surface, touch
screen, outside of ice
hopper
KAY 5 Sanitizer
37
Slowly pour two full pitchers of
hot water from the back sink
into the rinse area.
38
On top of the BIO-SHIELD®
dispenser open the pressure
relief knob by turning the knob
counter clockwise.
39
Remove the cap from the BIO-
SHIELD® dispenser.
continued X

Manitowoc Multiplex Ms-8 Specifications

General

Brand	Manitowoc
Model	Multiplex Ms-8
Category	Ice Maker
Language	English