MDC XT 14E 2021 - Annual Service Intervals

www.marketdirect.com.au
I
Ph: 1300 494 494 I ©Copyright Page | 77
Every 6 MONTHS / 5,000KM SERVICE
CHECKED
Hitch
• Check hitch bolts to 90Nm
Handbrake
•
Check cable and adjust if necessary
Hand
winch
• Check brake function and webbing
Suspension
• Lubricate and check bushes for excess movement.
• Torque bolts to 190Nm
Brakes
• Inspect and adjust. Check lining thickness and drum
wear
Wheel
bearings
• Remove, clean and re-lubricate. Inspect for wear and
replace if necessary
Wheel
Nuts
• Inspect condition and torque to 125Nm (12mm studs)
(140Nm 14mm studs alloy rims), (200Nm 14mm studs
steel rims)
Tyres
• Inspect for abnormal wear, damage, and pressure
Lights
•
Check all lights are functioning
Battery
• Check terminals and voltage at full charge
Seals
• Check condition and correct latch/lock adjustment for
correct 30-50% compression
General
fixings
• Check all structural fixing are secure.
Seals &
Latches
• Check all seals on doors and hatches compress 30-
50%. All seals in serviceable condition and free of
damage.
Suspension
• Grease bushes and check for play.
• Check torque on suspension hanger bolts (190nm)
• Check retaining chain shackles tight.
Service Centre: Notes:
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________