Part Number 9294844 April 6, 2023 67
Section 4 Maintenance
ICE MACHINE SANITIZING
To be done every three (3) months.
1. Use an approved sanitizing solution ratio noted.
Amount of Luke Warm
Water
Amount of Sanitizer
5 gallons (20 Liters) Use 1/4 ounce (15 ml) household
bleach per gallon or approved
sanitizer that provides 100ppm
available chlorine. Consult
manufacturer’s instructions for ratio.
2. Fill reservoir and evaporator with sanitizer/water
solution.
3. Verify the compressor rocker switch is in the OFF
position, then reconnect power and run the gear motor
for 10 minutes.
4. Move the compressor rocker switch to the ON position.
The ice machine will make ice with the sanitizer/water
solution and deposit the ice in the bin/dispenser. Make
ice for 20 minutes - add sanitizer/water solution as the
water level in the reservoir drops.
NOTE: Do not allow the sanitizer/water level to drop below
the sensing probes. The ice machine will start a 20 minute
delay period if the sensing probes lose contact with the
water for more than 10 seconds. If this happens, refilling the
reservoir, then disconnecting and reconnecting power will
restart the ice machine.
5. Move the compressor rocker switch to the OFF position
and disconnect power.
6. Drain the evaporator/reservoir and reinsert the drain
hose into the hose clip.
7. Remove blocking from under reservoir float and
reinstall reservoir cover.
8. Turn on the ice making water supply, reconnect power
and move the compressor rocker switch to ON.
9. Allow the ice machine to run for 20 minutes, then place
the compressor rocker switch in the OFF position,
disconnect power and discard all ice produced.
n
Warning
This ice production will contain residual cleaning
chemicals and must be discarded.
10. Replace all cleaned parts in their correct positions.
BIN / DISPENSER DESCALE, CLEAN, & SANITIZE
Heavy accumulations of scale may require disassembly of
the bin and dispenser parts, See “Full Disassembly Descale,
Clean & Sanitize”.
1. Disconnect power to the unit to prevent injury.
2. Remove the unit top by removing four thumbscrews.
DESCALING
To be done every six (6) months. Skip to “Sanitizing” if just
sanitizing the bin/dispenser.
1. Use an approved descaling solution ratio noted.
NOTE: For safety and maximum effectiveness, use the
solution immediately after dilution.
Amount of Luke Warm
Water
Amount of Ice Machine Cleaner
5 gallons (20 Liters) Use approved ice machine cleaner.
Consult manufacturer’s instructions
for ratio to make up 1 container of
solution.
SANITIZING
To be done every three (3) months.
1. Use an approved sanitizing solution ratio noted.
Amount of Luke Warm
Water
Amount of Sanitizer
5 gallons (20 Liters) Use 1/4 ounce (15 ml) household
bleach per gallon or approved
sanitizer that provides 100ppm
available chlorine. Consult
manufacturer’s instructions for ratio.
To Next Page
Loading...
