ODES UTV Desertcross 1000cc-3 - Periodic Maintenance

2.PERIODIC MAINTENANCE
2-
3
Fuel line*
● Check fuel hose for cracks or damage..
● Replacement fuel hose every 48 months
● Replacement fuel filter every 24 months
O
O
O
Engine oil
● Replace (Check oil level every month) .
O
O
O
O
Engine oil filter
● Replace.
O
O
O
Differential and
gearbox oil
● Check oil level/oil leakage.
● Replacement every 24 months.
O
O
Brake*
●Check operation/brake pad wear/fluid
leakage.
●Brake fluid needs to be above the lowest
position.
●Correct if necessary. Replace pads/disk if
worn to the limit.
O
O
O
O
O
Accelerator pedal*
●Check operation and free play.
O
O
O
O
O
Wheels*
●Check balance/damage/ run out
●Repair if necessary.
O
O
O
O
Wheel bearings*
●Check bearing assemblies for looseness
or damage..
●Replace if damaged.
O
O
O
O
Front and rear
Suspension*
●Check no deformation and looseness.
●Correct if necessary.
O
O
Steering system*
●Check operation and no looseness.
●Repair if damage.
●Check toe-in/Adjust if necessary.
O
O
O
O
O
Rear knuckle
pivots and
suspension arms*
●Lubricate with lithium-soap-based
grease.
O
O
O
Drive shaft
universal joint*
●Lubricate with lithium-soap-based
grease.
O
O
O
Engine mount*
●Check for cracks or damage.
●Correct bolt tightness.
O
O
O
Front and rear
axle boots*
●Check operation.
●Replace if damage.
O
O
Stabilizer
bushings*
●Check for cracks or damage.
O
O
O
Fittings and
fasteners*
●Check all chassis fittings and fasteners.
●Correct if necessary.
O
O
O
O
O
Battery
●End connection
O
O
O
O
Lamp and
steering indication
●Operation
O
O
O
O
O