Paul FOCUS 200 - Appendices; Checklist a Maintenance Work for Users

55 pages

Save Page as PDF

To Next Page

To Previous Page

6 Appendices

Checklist A Maintenance work for users

Maintenance work Enter date in quarter

1st Replace both filters in the ventilation unit (filter replacement cycle 90 days)

Quarter

Year

I II III IV

20...

2nd Extract air supplementary filter / clean the filters in extract air valves (filter replacement cycle approx. 2

months)

Quarter

Year

I II III IV

20...

3rd Replace other filters in the ventilation tube system

Quarter

Year

I II III IV

20...

Main Page

Table of Contents3
Introduction5
General5
Validity5
Target Groups5
Qualification of Target Group5
Users5
Qualified Personnel5
Conformity5
Proper Use6
Operation of the Unit6
Intended Use6
Provisions for Operation with Fireplaces6
Guarantee Conditions, Warranty and Liability6
Guarantee Conditions6
Warranty6
Liability7
Safety7
Symbols Used7
Safety Regulations7
Safety Instructions - General7
Safety Instructions - Installation8
Installation Conditions8
Instructions for the User and Qualified Personnel8
Product Description8
Control Panels9
Main Components9
Type Label9
Frost Protection9
Available Control Modules10
LED Control Panel10
LED Control Panel Control Functions10
Signals Used to Indicate Operating and Error Conditions11
TFT Control Panel12
TFT Control Panel Operations and Signals13
Menu Structure of the TFT Control Panel14
Main Menu Information15
Sub-Menu Current Message15
Sub-Menu Last Message15
Sub-Menu Fan Speeds16
Sub-Menu Current Device Status16
Sub-Menu Software Versions16
Sub-Menu Connected Units16
Sub-Menu Filter Running Time16
Sub-Menu Operating Hours16
Main Menu Settings16
Sub-Menu Filter17
Sub-Menu Frost Protection17
Sub-Menu Automatic17
Automatic Timer17
Automatic Sensor19
Sub-Menu Date/Time19
Sub-Menu Language Selection19
Sub-Menu Screen Dimming19
Sub-Menu Key Lock20
Sub-Menu Summer Ventilation Without Bypass20
Sub-Menu Supply Heater20
Sub-Menu Ground Heat Exchanger Shutter20
Sub-Menu Brine Defroster Cooling21
Boost Ventilation Mode with External Boost Ventilation Key21
Maintenance by the User21
Replacing the Unit Filters21
Resetting the Filter Running Time24
Reset Filter Running Time with LED Control Panel24
Reset Filter Running Time with TFT Control Panel24
What Should I Do in Case of a Fault25
Disposal25
Chapter for Qualified Personnel26
General System Configuration26
Installation Requirements26
Transport and Packaging26
Checking the Scope of Delivery27
Mounting27
Wall Mounting27
Fitting on Floor Stand (Optional)29
Connecting the Ventilation Tubes30
Connecting the Condensate Drain Hose31
Electrical Connections33
Adapter Board Connection33
Connecting TFT Control Panel34
Connecting Several TFT Control Panels34
Connecting the LED Control Panel35
Connecting External Boost Ventilation Keys35
Connecting External Sensors36
Connecting the Status Relay36
Connecting External Release36
Connecting Digital Inputs and Outputs36
Operation Without Connected Control Panel37
Commissioning the FOCUS Unit37
Readiness for Operation37
Adjusting the Air Volume Flow37
Adjusting the Nominal Air Volume Flow with TFT Control Panel37
Adjusting the Nominal Air Volume Flow with LED Control Panel38
Adjusting the Valves38
Menu Settings by Qualified Persons/Service Staff38
Main Menu Setup39
Sub-Menu Frost Protection39
Sub-Menu Fan Speeds39
Sub-Menu Supply Heater40
Sub-Menu Summer Ventilation Without Bypass40
Sub-Menu Ground Heat Exchanger Shutter41
Sub-Menu Reset to Factory Data41
Maintenance and Repair by the Qualified Personnel41
Inspection and Cleaning of the Heat Exchanger42
Swapping the Heat Exchanger Type45
Swapping the Heat Exchanger for the Summer Box45
Error Display and Troubleshooting45
Error Display with LED Control Panel45
Error Displays with TFT Control Panel46
Technical Description47
Unit Types47
Air Connection Design Versions47
Technical Specification47
Dimensions49
FOCUS Circuit Plan50
Master Controller Terminal Assignment51
Appendices52
Checklist a Maintenance Work for Users52
Checklist B Maintenance Work for Qualified Personnel53
Commissioning and Handover Protocol54
Air Volume Protocol55

Related product manuals

Paul FOCUS 200 Base

40 pages

Paul FOCUS 200 Base Series

39 pages

Paul CLIMOS F 200 Eco

Paul FOCUS 200 - Appendices; Checklist a Maintenance Work for Users

Table of Contents

Related product manuals