Roxell SparkCup - User Manual

28 pages

Save Page as PDF

To Next Page

To Next Page

Loading...

02501427

*02501427*

025-0821

Spark

cup

TM

User Guide

EN ENGLISH

Original User Guide

Questions and Answers

M
Mrs. Erica AtkinsSep 2, 2025
How to stop birds perching on Roxell SparkCup Farm Equipment lines?
- J
  Jeremiah HansenSep 2, 2025
  If birds are perching on the lines of your Roxell Farm Equipment, it could be due to several reasons. Ensure a cable for poultry perch guard is installed when needed. If present, make sure the cable is correctly connected, turned on, and check for short circuits. The cable should also be stretched enough, consulting an expert if needed. Verify the connection between the poultry perch guard and the line, using the correct high voltage cable. Ensure the profile has correct earthing. For breeders/layers, winch up the lines every evening and encourage birds to move before lights are switched off.
D
davidvargasAug 31, 2025
Why are the valves leaking in my Roxell SparkCup?
- Y
  Yolanda FarleyAug 31, 2025
  If you're experiencing leaking valves in your Roxell Farm Equipment, it could be due to several reasons. If the system was dirty when starting up, rinse the lines before using them. Bad water quality can also cause this issue; have the water tested by a specialist. Additionally, vaccines and medicines can contribute to leaks; rinse the lines before and after administering them. Ensure the water isn't polluted by regularly replacing the filter cartridge and using clear water. Finally, the use of certain detergents, disinfectants, or medicines may cause leaks; consult the list of allowed products and check supplier specifications before use.
D
Diana ThomasAug 29, 2025
What causes high water pressure on Roxell SparkCup line?
- M
  Mary WintersAug 29, 2025
  If the water pressure on the line in your Roxell Farm Equipment is too high, first ensure that the pressure regulator is not in the 'rinsing' position and put it in the correct position. If the issue continues, the pressure regulator may be defective and require replacement or repair.
C
Collin DurhamAug 27, 2025
How to fix individual cups running over in Roxell Farm Equipment?
- T
  Tonya BlairAug 28, 2025
  If individual cups in your Roxell Farm Equipment are running over, there's probably trash in the valve. Try moving the valve up and down to flush out any particles. If the problem persists, you may need to replace the valve.
J
jonesaprilAug 27, 2025
Why are birds not getting enough water from Roxell SparkCup Farm Equipment?
- M
  Megan MendozaAug 27, 2025
  If birds aren't getting enough water from your Roxell Farm Equipment, several factors could be at play. First, ensure the water supply isn't restricted and meets specifications. If you're raising young birds, the pressure might be too high; use float balls for at least the first 7 days and adapt the pressure accordingly. Also, check that the drinking lines aren't suspended too high and adjust their height. Finally, inspect the filters and lines for any trash or clogs, replacing filters or cleaning the line as necessary.
E
edward50Aug 25, 2025
What to do if sections of cups are running over in Roxell Farm Equipment?
- D
  Donna JohnsonAug 25, 2025
  If sections of cups in your Roxell Farm Equipment are running over, it's likely due to air in the line. To resolve this, let the air escape through a cup valve or flush the line completely.
E
Ellen PenaAug 22, 2025
How to stop water wastage in Roxell Farm Equipment?
- C
  Chad TaylorAug 23, 2025
  If your Roxell Farm Equipment is experiencing water wastage, check the height of the line. Adjusting it to the correct level should resolve the issue.

Summary

Disclaimer

System General Information

Legal and Safety Compliance

Compliance with legal regulations and safety rules for assembly and operation.

Product Intended Use and Liability

Defines intended use, misuse, and manufacturer liability for product damage.

User and Technician Qualifications

Specifies user and technician qualifications for product operation and maintenance.

Storage, Transport, and Dismantling Procedures

Guidelines for storing, transporting, and environmentally disposing of system components.

Environmental Information and Noise Levels

WEEE disposal, waste handling for EU customers, and noise emission limits.

Safe Equipment Lockout Procedure (LOTOTO)

Procedure for safely de-energizing equipment before maintenance or repair.

PPE and Workplace Lighting Requirements

Requirements for PPE and minimum illuminance levels for safe operation.

Electrical Equipment Safety Precautions

Precautions for electrical components, control panels, and drive units.

Understanding Safety Signs and Signal Words

Explanation of danger levels (DANGER, WARNING, CAUTION) and safety symbols.

Water Quality Parameters and Effects

Maximum Allowable Water Concentrations

Table of maximum allowable concentrations for various water parameters.

Algae, Nutrients, and Water System Impact

Impact of phosphates, nitrates, and algae on water systems and animal health.

Impact of Iron Contamination in Water

Impact of iron in water on system, health, and medication effectiveness.

Effects of Water Hardness and Calcium

Effects of water hardness and calcium deposits on the system and consumption.

Medication Effects on Water Lines

How certain medications can affect water lines and cause deposits or growth.

Cleaning and Disinfection Methods

Methods for cleaning inorganic and organic deposits using specific agents.

Sparkcup Operators Guide

Pre-Chick Arrival System Setup

Steps for setting up water pressure, flushing lines, and installing components.

System Operation During Bird Growth

Adjusting water levels and lines for different bird ages and types.

System Operation and Density Guidelines

Bird Density and Climate Guidelines

Recommended bird density per cup and climate considerations for operation.

Step-by-Step System Operation

Step-by-step instructions for operating the drinking system during the flock.

Replacing Sparkcup Cups and Valves

Small Cup Disassembly Guide

Instructions and diagrams for disassembling small Sparkcup cups.

Medium and Big Cup Disassembly

Instructions and diagrams for disassembling medium and big Sparkcup cups.

Valve Replacement and Sealing

Steps for replacing valves, including sealing and cup reassembly.

Water Supply and Satellite Drinker Use

Water Supply Specification Check

Test procedure to verify if water supply meets system requirements.

Satellite Drinker Installation and Use

Using satellite drinkers for starting up chicks and their installation process.

Disinfectants for Pollutant Removal

Manual Flushing System Operation

Semi-Automatic Flushing System

Automatic Flushing System Operation

Sparkcup Troubleshooting Guide

Hand Winch Operation and Safety

Hand Winch General Safety Rules

Critical safety instructions for operating the hand winch system.

Hand Winch Troubleshooting Guide

Common problems and corrective actions for hand winch operation.

Hand Winch Maintenance Instructions

Procedures for cleaning and maintaining the hand winch system.

Declaration of Incorporation of Machinery

EC Declaration of Conformity

Roxell SparkCup Specifications

General

Brand	Roxell
Model	SparkCup
Category	Farm Equipment
Language	English

Related product manuals

Preview: Roxell Minimax Line

Roxell Minimax Line

Roxell KiXoo in line

Preview: Roxell FLEX-AUGER FA 55

Roxell FLEX-AUGER FA 55

Roxell FLEX-AUGER FA 75

Roxell FLEX-AUGER FA 90

Roxell FLEX-AUGER FA 125