Segway Personal Transporter SE Service Manual
x
Fasteners
WARNING!
• Use only Segway-approved fasteners. Other fasteners may not perform as expected and may come loose.
• Do not tighten or reuse any fastener except the screws used to attach the batteries, wheel nuts, and LeanSteer frame.
Instead, when any other fastener is loose or removed, replace the fastener with a new Segway-approved fastener. See
“Fasteners,” page C–1, for more information.
• Before using a fastener, make certain the fastener is the correct size and type with any necessary washer and thread
lock in place (see Table C–1, p. C–2).
• Since the pre-applied thread lock compound is intended for single use only, reuse of fasteners is not permitted with the
exception of the wheel nuts, battery fasteners, and LeanSteer frame fasteners.
• Do not attempt to repair any stripped or damaged screw hole. Instead, replace the part. If a replacement part is not
available, do not reassemble.
• Insert fasteners slowly and carefully. Do not cross-thread or over-tighten fasteners. Tighten only to the prescribed
torque.
• At the factory, Segway installs self-tapping fasteners intended for one-time use only. Service replacement fasteners are
not self-tapping and, therefore, may differ slightly in appearance from the comparable factory-installed fasteners.
• Failure to adhere to these warnings could lead to serious injury or death or damage to property.
Eye Protection
WARNING!
• When procedures require the use of safety glasses (such as those in which a mallet or solvent is used), failure to wear
eye protection could result in serious injury.
ESD Procedures
CAUTION!
• When a repair involves opening the console or chassis cover, best-practice electrostatic discharge (ESD) control
procedures must be followed. Failure to follow ESD procedures could result in personal injury or damage to property.
SOLVENTS
CAUTION!
• This manual refers to the use of isopropyl alcohol and ammonia or ammonia-based window cleaner in certain cleaning
procedures. Use of any other type of solvent is not allowed.
Questions
WARNING!
• If you have any questions about the instructions in this guide, please contact a Segway Service Representative to avoid
confusion leading to serious injury or death or damage to property.
General Safety Precautions
To Next Page
Loading...
