114
* Before installing new properly gapped spark plugs at preseason
preparation, it is suggested to burn excess storage oil by starting
the engine with the old spark plugs. Only perform this operation
in a well-ventilated area.
** Lubricate whenever the vehicle is used in wet conditions (wet
snow, rain, puddles).
Drive Belt Condition
✓✓ ✓
Condition of Drive and Driven Pulleys ✓✓✓
Cleaning of Drive and Driven Pulleys ✓✓
Retorquing of Drive Pulley Screw ✓✓✓
Driven Pulley Preload ✓✓
Brake Fluid Level
✓✓ ✓✓
Brake Fluid (change once a year) ✓
Brake Condition ✓✓ ✓✓
Drive Chain Tension
✓✓✓
Countershaft Lubrication** ✓✓✓
Chaincase Oil Level ✓✓ ✓
Chaincase Oil Change ✓✓
Lubrication of Drive Axle End Bearing** ✓✓✓
Steering and Front Suspension Mechanism
Lubrication**
✓✓✓
Steering and Front Suspension Mechanism
Condition
✓✓✓
Wear and Condition of Skis and Runners ✓✓ ✓
Steering and Ski Leg Adjustment ✓✓✓
Suspension Adjustments
AS REQUIRED
Suspension Lubrication** ✓✓
Suspension Condition ✓ ✓✓✓
Suspension Stopper Strap Condition ✓✓
Track Condition ✓✓✓
Track Tension and Alignment ✓
AS REQUIRED
Spark Plugs* Condition
✓✓ ✓
Battery Condition (if so equipped) ✓✓✓✓
Headlight Beam Aiming ✓✓
Wiring Harnesses, Cables and Lines ✓✓✓
Operation of Lighting System
(HI/LO Beam, Brake Light, etc.),
Test Operation of Engine Cut-Out Switch
and Tether Cut-Out Switch
✓✓ ✓
Rags in Air Intake and Exhaust System
✓✓
Engine Compartment ✓✓✓
Vehicle Cleaning and Protection ✓✓✓
PERIODIC MAINTENANCE CHART
➀➁➂➃➄➅
Mmo2003-003a.book Page 114 Tuesday, March 19, 2002 2:22 PM
To Next Page
Loading...
