SolaX Power T-BAT Series - Note on this Manual; Scope of Validity; Target Group; Symbols Used

1 Note on this Manual
1.1 Scope of Validity
This manual is an integral part of T-BAT Series. It describes the assembly,
installation, commissioning, maintenance and failure of the product. Please read
it carefully before operating.
T-BAT SYS-HV
1.2 Target Group
This manual is for qualifed electricians. The tasks described in this manual may
only be performed by qualifed electricians.
DANGER!
“DANGER” indicates a hazardous situation which, if not avoided,
will result in death or serious injury.
WARNING!
“WARNING” indicates a hazardous situation which, if not avoided,
could result in death or serious injury.
CAUTIOIN!
“CAUTION” indicates a hazardous situation which, if not avoided,
could result in minor or moderate injury.
NOTE!
“NOTE” provides tips that are valuable for the optimal operation
of your product.
T-BAT H 5.8
NOTE: There are 4 models for T-BAT system, including BMS and battery packs.
Please refer to section 3.3.1 T-BAT SYS HV Conguration Liston page 11 for more
information.
T-BAT PACK-HV
HV11550
1.3 Symbols Used
4.5 CABLE CONNECTION.........................................................................................................
4.5.1 .................CONNECTING POWER CABLES BETWEEN BATTERY PACKS
4.5.2 ....................................................CONNECTING POWER CABLES TO INVERTER
4.5.3 CONNECTING CAN COMMUNICATION CABLE................................................
4.5.4 ............................................CONNECTING RS485 COMMUNICATION CABLE
4.5.5 .......................................................................................CONNECTING GROUND WIRE
4.6 OVERVIEW OF INSTALLATION......................................................................................
5 COMMISSIONING...................................................................................................................................
5.1 CONFIGURING BATTERY SYSTEM.............................................................................
5.2 COMMISSIONING..................................................................................................................
5.3 STATUS INDICATORS...........................................................................................................
5.3.1 BMS ....................................................................................................................................................
5.3.2 BATTERY .............................................................................................................................PACK
5.4 SHUTTING DOWN T-BAT SYSTEM............................................................................
6 TROUBLESHOOTING..........................................................................................................................
6.1 TROUBLESHOOTING...........................................................................................................
7 DECOMMISSIONING...........................................................................................................................
7.1 DISMANTLING THE BATTERY.........................................................................................
7.2 PACKAGING................................................................................................................................
Contents
18
18
20
24
25
26
29
30
30
31
33
33
34
34
35
35
38
38
38
8 MAINTENANCE AND WARRANTY................................................................................................
8.1 MAINTENANCE........................................................................................................................
8.2
WARRANTY..................................................................................................................................
39
39
39
4.5.6 .....................................................................................................OVERALL INSTALLATION
27